Abstract:The co-removal of CO2 while removing SO2 and NOx from industrial flue gas has great potential of carbon emission reduction but related research is lacking. In this study, a wet scrubbing process with various urea solutions for desulfurization and denitrification was explored for the possibility of CO2 absorption. The results showed that the urea-additive solutions were efficient for NOx and SO2 abatement, but delivered < 10% CO2 absorption efficiency. The addition of Ca(OH)2 dramatically enhanced the CO2 absorption, remained the desulfurization efficiency, unfortunately restricted the denitrification efficiency. Among various operating parameters, pH of solution played a determining role during the absorption. The contradictory pH demands of CO2 absorption and denitrification were observed and discussed in detail. A higher pH of solution than 10 was favorable for CO2 absorption, while the oxidizing of NO to NO2, NO2- or NO3- by NaClO2 was inhibited in this condition. When 7 < pH < 10, it was favorable for the conversion and absorption of NO and NOx. However, the conversion of HCO3- to CO32- was significantly inhibited, hence preventing the absorption of CO2. Large part of Ca(OH)2 became CaCO3 with a finer particle size, which covered the unreacted Ca(OH)2 surface after the reaction. Kinetic analysis showed that the CO2 absorption in urea-NaClO2-Ca(OH)2 absorbent was controlled by chemical reaction in early stage, then by ash layer diffusion in later stage.

ICOPE-15-C089 Experimental study on CO_2/SO_2/NO_X simultaneous absorption and separated desorption using compound amine sulphone solution

ICOPE-15-C088 Experimental research on simultaneous removal of CO_2, SO_2 and NOx by amine-sulphone solution

Experimental Study on Simultaneous Absorption and Desorption of CO2, SO2, and NOx Using Aqueous N-Methyldiethanolamine and Dimethyl Sulfoxide Solutions

Experimental Studies on Absorption and Regeneration Performance of Compound Amine Sulphone Solvents on CO2, SO2 and NOx Capture

Experimental Research on Absorption Characteristics of CO2， SO2 and NOx in Compound Solution of MDEA and DMSO

Experimental Study on the Simultaneous Removal of SO_2 and NO by High Efficiency Liquid Absorbent

Novel Method for High-Performance Simultaneous Removal of NOx and SO2 by Coupling Yellow Phosphorus Emulsion with Red Mud

Simultaneous Removal of SO2 and NOx with Ammonia Combined with Gas-Phase Oxidation of NO Using Ozone

Multi-stage semi-coke activation for the removal of SO2 and NO

Effective Absorption Mechanism of SO2 and NO2 in the Flue Gas by Ammonium-Bromide-Based Deep Eutectic Solvents

Simultaneous removal of SO2 and NOx by combination of ozone oxidation and Na2S2O3solution spray

Kinetics for the Simultaneous Removal of NO and SO2 with Cobalt Ethylenediamine Solution

Experimental study on the influence of SO2 on the CO2 capture process

Simultaneous Absorption of SO2 and CO2 from Flue Gas Using Aqueous Ammonia

Experimental Study and Modified Modeling on Effect of SO2 on CO2 Absorption Using Amine Solution

Experimental studies on simultaneous removal of CO2 and SO2 in a polypropylene hollow fiber membrane contactor

Simultaneous wet absorption of SO2 and NOX with mixed Na2SO3 and (NH4)2SO3: Effects of mass concentration ratio and pH

Experiment on Simultaneous Absorption of NO and SO2 from Sintering Flue Gas by Oxidizing Agents of KMnO4/NaClO

The absorption behavior of SO 2 by amine alkyl organosilicon: Experimental analysis and numerical simulation

Performance and mechanism of CO2 absorption during the simultaneous removal of SO2 and NO by wet scrubbing process

Study on Coadsorption of SO2, NO, and CO2 over Copper‐supported Activated Carbon Sorbent in Different Operating Conditions