Abstract:The critical point is the end point of a phase equilibrium curve; liquid and its vapor can coexist under designated points. Close to the critical point, thermophysical properties present clear variations, especially in the region of 0.85P(cr)similar to P-cr Latent heat and liquid density in this region decrease more quickly than in lower-pressure areas, resulting in unique boiling heat transfer behavior. This region is also called the near-critical region. However, only a few scholars have discussed the heat transfer phenomenon; thus, it is difficult to ascertain the near-critical region's properties and characteristics from extant literature. In the present study, we conduct experimental investigations to explore the specificities of the heat transfer characteristics of carbon dioxide in horizontal flow within the near-critical region in a circular channel with a diameter of 4 mm. The operating pressure ranges from 6.26 MPa to 7.3 MPa with a mass flow rate between 200 and 400 kg/m(2) s, heat flux between 5 and 140 kW/m(2), and test section inlet temperature of -5 degrees C. Then, we examine the inner-wall temperature and heat transfer coefficient profiles at different pressures within the near-critical region. The results show that at high heat flux, departure from nucleate boiling (DNB) phenomenon presents with a sudden decrease in the heat transfer coefficient in the sub cooled region. The higher the heat flux, the more seriously deteriorating the heat transfer is. Interestingly, the temperature reaches its peak in the post-DNB region rather than at the critical vapor quality point. With an increase in pressure, DNB occurs early with lower vapor quality, and the temperature peak decreases at the given heat flux and mass flux. On the contrary, DNB is delayed with an increase in mass flux. A series of boiling heat transfer correlations in a subcooled region, two-phase flow region, and superheated region are proposed in addition to a new predictive correlation for critical heat flux in the near-critical region at a given mass flux. (C) 2018 Elsevier Ltd. All rights reserved.

Discussion on Near-Critical Heat Transfer Flow Experiment

Heat transfer and various convection structures of near-critical CO 2 flow in microchannels

Thermal Relaxation and Critical Instability of Near-Critical Fluid Microchannel Flow.

Numerical Simulation of Stability Behaviors and Heat Transfer Characteristics for Near-Critical Fluid Microchannel Flows

Poiseuille Rayleigh-Benard Convective Flow and Compressible Boundary Effects of Near-Critical Fluid in Microchannels

Numerical Analysis on the Thermal Responses of Near-Critical Fluid to Transient Cooling Process

Numerical Investigation of Near-Critical Fluid Convective Flow Mixing in Microchannels

Abnormal Microchannel Convective Fluid Flow Near the Gas–liquid Critical Point

Experimental and Numerical Studies on Enhanced Flow Boiling in Tube with Superwetting Micro-Finned Surfaces

Thermal-Mechanical Effects and Near-Critical Fluid Dynamic Behaviors in Micro-Scale

Experimental Investigations on the Boiling Heat Transfer of Horizontal Flow in the Near-Critical Region

Enhancing the Critical Heat Flux Using Microchanneled Surfaces

An Overview of Liquid–vapor Phase Change, Flow and Heat Transfer in Mini- and Micro-Channels

Microscale physics and macroscale convective heat transfer in supercritical fluids

Numerical Model Development for Critical Region Flow and Thermodynamic Transitions of CO2 Fluids in Microchannel

Experimental and Numerical Studies of Fluid Flow Confined in Microchannel

Single-phase flow and heat transfer in micro-channels

Investigation on Critical Heat Flux of Flow Boiling in Parallel Microchannels with Large Aspect Ratio: Experimental and Theoretical Analysis

EXPERIMENTAL STUDY ON THE CRITICAL HEAT FLUX OF NANOFLUID FLOW BOILING UNDER DIFFERENT CONDITIONS

A Molecular Dynamics Simulation on the Convective Heat Transfer in Nanochannels

Numerical simulation of flow and heat transfer in swirl microchannels