Abstract:In this paper, numerical simulations are performed using several low-Reynolds number k-ε turbulence models due to AKN, MK and V2F for the convection heat transfer of supercritical CO2 flowing through a heated vertical mini tube with inner diameter of 0.27 mm for various heat fluxes at relatively low Reynolds number of 2900. The predictions are compared with the corresponding experimentally measured values. The performance of various low Reynolds number k-ε turbulence models under normal and deteriorated heat transfer conditions are assessed. Results show that all the three models produce fairly good predictions of local wall temperature variations under normal heat transfer condition. The MK and V2F models give good predictions when the flow acceleration is not very strong. However, they respond insufficiently to the flow acceleration effect when it gets stronger. The V2F model is able to capture the general trends of deteriorated heat transfer due to the combined flow acceleration and buoyancy effects. The AKN model over-responds to the flow acceleration effect in most cases, and distorts the velocity profiles more severely than the V2F model where local heat transfer deterioration occurs. Further improvements of the turbulence models are needed for quantitative predictions. Detailed information obtained from the numerical results using V2F model is qualitatively analyzed to understand the mechanism of the special characteristics of the reduced heat transfer resulted from the buoyancy and flow acceleration. The redistribution of flow field induced by the buoyancy and flow acceleration effects is the main factor leading to the local heat transfer deterioration.

Investigation of trans-critical CO 2 horizontal mini-channel flow with multi-peak heat transfer behaviors

Visualization of R1233zd(E) Flow Boiling in Parallel Mini-channels

Characteristics of Heat Transfer for CO2 Flow Boiling in Mini_channel

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Heat transfer and various convection structures of near-critical CO 2 flow in microchannels

Characteristics of Heat Transfer for CO2 Flow Boiling at Low Temperature in Mini-Channel

Quantitative Visualization on Boundary Heat Transfer of Supercritical CO2 Mini-Channel Through-Flow (re=104) Via Pixelated Phase-Shifting Interferometry

Multi-effect Evaluation of Cooling Heat Transfer Performance for Supercritical CO2 Flowing in Micro-Channel

Quantitative visualization on boundary heat transfer of supercritical CO 2 mini-channel through-flow ( Re =10 4 ) via pixelated phase-shifting interferometry

Studies on the flow acceleration and bouyancy effects on the heat transfer to supercritical CO2 flowing through mini channel

Study of Trans-Critical CO2 Natural Convective Flow with Unsteady Heat Input and Its Implications on System Control

Characteristics of Flow Boiling Heat Transfer of Sub-Critical CO2 in Mini-Channels with Micro-Fins

Numerical Simulation of Stability Behaviors and Heat Transfer Characteristics for Near-Critical Fluid Microchannel Flows

Thermal and Hydrodynamic Characteristics of Supercritical Co2 Natural Circulation in Closed Loops

Convection Heat Transfer of Co2 at Supercritical Pressures in A Vertical Mini Tube

Study on the convective heat transfer characteristics of supercritical CO 2 in mini-channels under unilateral heating conditions for application in a compact solar receiver

Comprehensive evaluation on the thermal-hydraulic performance of supercritical CO2/R41 in a micro-fin tube

Experimental Research on a New Mini-Channel Transcritical CO2 Heat Pump Gas Cooler

Numerical Investigation of Heat Transfer Characteristics of scCO2 Flowing in a Vertically-Upward Tube with High Mass Flux

Numerical Analysis of Supercritical CO2 Flow and Heat Transfer Inside Porous Structures on a Microchip

Heat Transfer Characteristics of CO2 in a Horizontal Tube under Subcritical and Supercritical Pressures