Abstract:This study investigates the alternative of replacing noble metals by base metals as catalysts for selective hydrogenation of polyunsaturated hydrocarbons. Nickel catalysts are active for this type of reaction, but poorly selective. However, former calculations anticipated that Ni–Zn alloys could have higher selectivity to alkenes than monometallic Ni depending on the Ni/Zn atomic ratio in the alloy. In this contribution, Ni–Zn alloy nanoparticles supported on TiO2 are synthesized as catalysts for selective hydrogenation of acetylene and butadiene. The designed catalysts with 0.5 wt% Ni loading and various Ni/Zn nominal ratios are prepared by deposition–precipitation with urea (DPU). STEM-HAADF imaging coupled with EDS analysis reveals that Ni–Zn bimetallic particles are formed after reduction treatment at 450 °C. Alloying Ni with Zn leads to a slight increase in the average particle size and a broadening of the size distribution compared to monometallic Ni. However, the average Ni/Zn atomic ratio measured by EDS in the bimetallic particles is always higher than the nominal one, which could be due to Zn evaporation under the beam. The results of acetylene hydrogenation show that although the catalytic activity is slightly reduced after alloying Ni with Zn, the selectivity to ethylene is enhanced from 50% up to 85%, at the expense of the formation of oligomers (coupling products). However, the bimetallic Ni–Zn catalysts suffer from progressive deactivation in this reaction. During butadiene hydrogenation performed in the presence of an excess of propene, the bimetallic Ni–Zn/TiO2 catalysts are significantly more stable, with a high and constant selectivity to butenes (> 95%), compared with Ni/TiO2, which deactivates rapidly in the first hours. Some hypotheses concerning the observed differences in catalytic stability are discussed.

H2O as the Sole Hydrogen Source for Ni-Catalyzed Reduction of Alkenes

The Promoting Role of Minor Amount of Water in Solvent-Free Hydrogenation of Halogenated Nitrobenzenes

Application of Alkoxide in Catalytic Transfer Hydrogenation of Unsaturated Nitrogen Compounds

Efficient and Stable Cu-Ni/ZrO2 Catalysts for in Situ Hydrogenation and Deoxygenation of Oleic Acid into Heptadecane Using Methanol As a Hydrogen Donor

Electroreduction of unactivated alkenes using water as hydrogen source

CO2 Promoted Photoredox/ni-Catalyzed Semi-Reduction of Alkynes with H2O

Cooperative N-Heterocyclic Carbene/Nickel-Catalyzed Hydroacylation of 1,3-Dienes with Aldehydes in Water

Ionic Liquid Immobilized Nickel(0) Nanoparticles As Stable and Highly Efficient Catalysts for Selective Hydrogenation in the Aqueous Phase

Electrochemical Nickel‐Catalyzed Hydrogenation

Hydrogenation of Nitroarenes by Onsite-Generated Surface Hydroxyl from Water

Photocatalytic Hydrogenation of Alkenes Using Water as Both the Reductant and the Proton Source

O, N Coordination-Mediated Nickel Single-Atom Catalysts for High-Efficiency Generation of H2O2.

The Catalytic Behaviour in Aqueous-Phase Hydrogenation over a Renewable Ni Catalyst Derived from a Perovskite-Type Oxide.

Asymmetric Umpolung Hydrogenation and Deuteration of Alkenes Catalyzed by Nickel

General Strategy toward Hydrophilic Single Atom Catalysts for Efficient Selective Hydrogenation

Selective Reduction of O2 to H2O2 by Novel EDTA-Derived Ni-Nanoparticle-Set Nitrogen-Doped Carbon Catalysts

Effective Ensemble of Pt Single Atoms and Clusters over the (Ni,Co)(OH) 2 Substrate Catalyzes Highly Selective, Efficient, and Stable Hydrogenation Reactions

A Recyclable Electrochemical Reduction of Aldehydes and Ketones to Alcohols Using Water as the Hydrogen Source and Solvent

Bimetallic Ni–Zn/TiO2 catalysts for selective hydrogenation of alkyne and alkadiene impurities from alkenes stream

A general and robust Ni-based nanocatalyst for selective hydrogenation reactions at low temperature and pressure

Nickel-Catalyzed highly Efficient Chemoselective Reduction of Azoarenes to Hydrazoarenes in Water