Abstract:In this paper, a new ternary non-azeotropic mixture of HFC-161/125/143a (0.15/0.45/0.40 in mass fraction), as a promising mixed refrigerant to R404A, is presented. The ozone depletion potential (ODP) of the new refrigerant is zero and its basic thermodynamic properties are similar to those of R404A, but its global warming potential (GWP) is much smaller than those of R507A and R404A. Meanwhile, theoretical calculations show that, under the working condition I (the average evaporation temperature: −23 °C, the average condensing temperature: 43 °C, the superheat temperature: 28 °C, the subcooling temperature: 5 °C), the volumetric refrigerating effect and specific refrigerating effect of the new mixture are 2.33% and 15.48% higher, respectively, than those of R404A. The coefficient of performance (COP) of the new mixture is 5.19% higher than that of R404A and the pressure ratio of the new mixture is 0.82% lower than that of R404A. Equally, under the working condition II (the average evaporation temperature: −40 °C, the average condensing temperature: 35 °C, the superheating temperature: 30 °C, the subcooling temperature: 5 °C), the volumetric refrigerating effect and specific refrigerating effect of the new mixture are 2.24% and 20.58% higher, respectively, than those of R404A. The COP of the new mixture is 4.60% higher than that of R404A and the pressure ratio of the new mixture is similar to that of R404A. The performances of the new mixture and R404A are compared in a vapor compressor refrigeration apparatus originally designed for R404A under several working conditions (condensing temperatures: 35–45 °C, evaporation temperatures: −40–−20 °C). Experimental results show that the new mixture can obtain a higher COP, by 6.3% to 12.1%, and a lower pressure ratio, by 1.8% to 6.6%, compared to R404A; although the discharge temperature of the new mixture is slightly higher than that of R404A. The advantages of the new mixture will be further verified in the actual system.

Numerical Investigation on Thermodynamic Performance of CO 2 -Based Mixed Refrigerants Applied in Transcritical System

Numerical investigations on the performance of a single-stage auto-cascade refrigerator operating with two vapor-liquid separators and environmentally benign binary refrigerants

Theoretical Investigation on the Performance of a Modified Refrigeration Cycle Using Binary Zeotropic Hydrocarbon Mixture R170/R290

Theoretical and experimental study on a novel mixture refrigerant of R161 +R227ea

Experimental study of ternary mixture R32/R125/R161 as alternative refrigerant to R407C

Investigations on Performance of an Auto-Cascade Absorption Refrigeration System Operating with Mixed Refrigerants

Cycle Performance Studies on a New HFC-161/125/143a Mixture As an Alternative Refrigerant to R404A

Optimization Analyses on the Performance of an Auto-Cascade Absorption Refrigeration System Operating with Mixed Refrigerants

Thermodynamic Analysis and Experimental Investigation of Internal Heat Exchanger Influence on CO2 Trans-Critical Cycle Performance

Performance Analysis and Comparison Study of Transcritical Power Cycles Using Co2-Based Mixtures As Working Fluids

Thermodynamic Analysis and Experimental Investigation of Internal Heat Exchanger Influence on CO<sub>2</sub> Trans-Critical Cycle Performance

Thermodynamic performance assessment and application feasibility analysis of small heat pump water heater using CO2/R41 azeotropy mixture as refrigerant for sustainable development

Thermodynamic Analysis of Comprehensive Performance of Carbon Dioxide(R744) and Its Mixture with Ethane(R170) Used in Refrigeration and Heating System at Low Evaporation Temperature

Theoretical Study of the Optimal Proportion of Non-azeotropic Refrigerant Mixtures of R32 and R123

Experimental study on the transcritical cycle performance of a closed-loop heat pump drying system based on R744/R290/R32 ternary refrigerant

Experimental and Theoretical Assessments on the Systematic Performance of a Single-Stage Air-Source Heat Pump Using Ternary Mixture in Cold Regions

Performance Of Refrigeration & Heat Pump System By Using Binary Mixtures Of R32/R744

Experimental Investigation Of A Transcritical Co2 System For Simultaneous Heating And Cooling Performance

Thermodynamic Performance Analysis of CO 2 Transcritical Refrigeration Cycle Assisted with Mechanical Subcooling

Experimental Investigation on the Performance Influencing Factors of a Transcritical CO2 System

Thermodynamic Analysis of Transcritical CO2 Ejector Expansion Refrigeration Cycle with Dedicated Mechanical Subcooling