Abstract:The field balancing of flexible rotors is one of the key techniques to reduce vibration of large rotating machinery. Although in recent decades the balancing theory has been thoroughly studied and various balancing techniques have been well developed, the present balancing methods are still remain for further improvements in accuracy and efficiency. Firstly, most balancing methods need large numbers of trial runs to obtain the vibration responses of trial weights in different correcting planes. Secondly, the vibration response in each measured section is always taken from a single sensor, and thus are lack of comprehensive vibration information of rotor. In fact, the movement of rotor is a complex spatial motion, which can't be objectively and reliably described just with a single sensor in each beating section. In order to overcome above shortcomings of traditional balancing methods, this paper presents a new field balancing method for flexible rotors, which is based on adaptive neuro-fuzzy inference system (ANFIS). The new method successfully applies the information fusion, ANFIS and computer simulation together. It integrates and fully utilizes the information supplied from all proximity sensors by holospectrum for enhancing the balancing efficiency and accuracy. A fuzzy model is established to simulate the mapping relationship between vibration responses and balancing weights by using the ANFIS. The inputs into ANFIS are the amplitudes and phases of integrated vibration responses, while the outputs are the mass and azimuth of balancing weights. A fuzzy set with three membership functions (MFs) is used to describe the magnitude of vibration amplitudes or of balancing weights. Another fuzzy set with five MFs is used to describe the quadrant of vibration phases or of balancing weights. Based on the historical balancing data, a combination of least-square and back-propagation gradient descent methods is then used for training ANFIS membership function and node-parameters to model input (vibration response)/output (balancing weight) data. The simulation study shows that the ANFIS can obtain satisfactory balancing result after a single trial run. At the same time, with the help of computer simulation, different correction schemes can be compared and rapidly simulated to direct balancing operation. Finally, the effectiveness of the new method was validated by the experiments on balancing rig and in the field balancing practice of several 300MW turbo-generator units.

Time-Domain Method For Correction Of Aerodynamic Loads In High-Frequency Force Balance Tests

Rigid Rotor Dynamic Balancing by Two-Plane Correction with the Influence Coefficient Method

HFFB Technique and Its Validation Studies

Optimal Force-Balance Control of Closed-Loop Sensing Systems with Time Delay

A New Hypersonic Wind Tunnel Force Measurement System to Reduce Additional Bending Moment and Avoid Time-Varying Stiffness

Mode Shape Linearization and Correction in Coupled Dynamic Analysis of Wind‐excited Tall Buildings

Real-Time Hybrid Test Method for Floating Wind Turbines: Focusing on the Aerodynamic Load Identification

Damping identification using weighted fitting of Frequency-response-function (WFF) method

Fast Bayesian modal parameter identification method based on short-time Fourier transform

High Accuracy Parameters Measurement of Dynamic Balancing Signal Based on Phase Difference Correction Technology

Measurement technology in hypersonic wind tunnel

Model-Selection Uncertainty Quantifications in HFFB Dynamic Analyses of a Complex Tall Building

Efficient Forced Response Minimization Using a Full-Viscosity Discrete Adjoint Harmonic Balance Method

A New Dynamic Balance Framework Based on Blind Source Separation under Multiple Fault Conditions

Identification of Lateral-Directional Aerodynamic Parameters via an Online Correction Wind Tunnel Virtual Flight Test

Application of adaptive neuro-fuzzy inference system in field balancing

A Synchronous Holo-Balancing Method for Flexible Rotors Based on the Modified Initial Phase Vector

Buffeting Response Prediction of Long-Span Bridges Based on Different Wind Tunnel Test Techniques

A Harmonic Balance Method Combined with Dimension Reduction and FFT for Nonlinear Dynamic Simulation

Effects of Corner Modification on the Wind-Induced Responses of High-Rise Buildings

On line balancing of high speed magnetic suspended flywheel system under force free control of imbalance