Abstract:Oxy-coal combustion steam system of near-zero emission (OCCSS) proposed by the authors' research group is a new power generation system which uses coal-based syngas or demineralized coal as fuel. The combustion process has the characteristics of high temperature, high pressure, high water vapor concentration and high oxygen concentration. The key point of understanding the combustion process is to study the combustion characteristics under complex conditions. As an important part of the combustion characteristics, the study of the flammable limit of syngas has important value for the design and operation of the burner. The paper introduces the study of the lower flammability limit (LFL) of hydrogen/carbon monoxide mixtures (H-2/CO) based on a spherical explosion vessel. The internal diameter was 337 mm and the volume is 20.04 L. The experimental procedure was based upon ASTM E2079-07. Effects of initial temperature, H-2/CO ratio, and different dilution with N-2 or water vapor were studied. Results show LFL of the syngas decreases with the temperature, which indicates higher initial temperature can promote flame propagation. The study also shows the flame temperature at LFL is approximately constant regardless of the unburned gas temperature. Experiments on the effects of different H-2 contents both which is from 0 to 100% in both pure oxygen and water vapor show more H-2 in the mixed gas will help to lower the LFL, and the presence of H2O can promote the flame propagation. In addition, studies on the dilution effects of H2O and N-2 on LFL show the addition of water vapor not only reduces the reactant concentration, but also affects the gas flame propagation through affecting the chemical process. Finally, Le Chatelier's rule is used to estimate the LFL of the H-2/CO mixture and compared with the experimental data. The results indicate the mixing rule is appropriate for the predication of LFL of H-2/CO in O-2/H2O environment by considering N-2 or CO2 as a kind of dilution in the combustible gas. (C) 2017 Hydrogen Energy Publications LLC. Published by Elsevier Ltd. All rights reserved.

Experimental measurements on chemical reaction and thermal conductivity of the H<sub>2</sub>/CO<sub>2</sub>/CO/CH<sub>4</sub>/H<sub>2</sub>O system using the short-hot-wire method at 664-915 K and 9.2-22.2 MPa

Thermal conductivity measurements of the H<sub>2</sub>/CO<sub>2</sub> mixture using the short-hot-wire method at 323.15-620.05 K and 2.14-9.37 MPa

Prediction of the Thermal Conductivity of H2/CO2/CO/CH4/H2O Mixtures at High Temperatures and High Pressures Based on the Extended Corresponding States Principle

Isobaric Heat Capacity and Density of Supercritical H2O/CO2 Mixtures: Measurements in a Multifunction Apparatus

Density Measurements of the H-2-CO2-CH4-CO-H2O System by the Isochoric Method at 722-930 K and 15.4-30.3 MPa

Pvt Measurements Of The H-2-Co2-Ch4-Co-H2o System At 740-939 K And 18.1-34.7 Mpa With An Isochoric Apparatus And The Development Of A Virial Equation Of State

Viscosity Measurements of the H-2-CO2, H-2-CO2-CH4, and H-2-H2O Mixtures and the H-2-CO2-CH4-CO-H2O System at 280-924 K and 0.7-33.1 MPa with a Capillary Apparatus

High Temperatures and High Pressures Brillouin Scattering Studies of Liquid H2O+CO2 Mixtures

A Review of Experimental Researches on the Thermophysical Properties of Hydrogen-Containing Mixtures at High Temperatures and High Pressures

Apparatus for Investigation of Heat Transfer to H2O/CO2 Mixtures in Both Near-Critical and Supercritical Regions

Viscosity Measurements of the H2–CO2, H2–CO2–CH4, and H2–H2O Mixtures and the H2–CO2–CH4–CO–H2O System at 280–924 K and 0.7–33.1 …

Development of a new PVT Measurement Method for the Hydrogen Mixture at High Temperatures and High Pressures

Measurements and correlation of hydraulic resistance for H 2 O/CO 2 mixtures at supercritical pressure

Density Data of Two (H2 + CO2) Mixtures and a (H2 + CO2 + CH4) Mixture by a Modified Burnett Method at Temperature 673 K and Pressures Up to 25 MPa

On-line Measurement of Isobaric Specific Heat Capacity for Endothermic Hydrocarbon Fuel at High Temperature

Measurement of Thermal Conductivity for Systems of Methyl Ethyl Ketoxime with Methyl Ethyl Ketone and N-Hexane Separately

A Numerical Study on the Thermal Conductivity of H2O/CO2/H2 Mixtures in Supercritical Regions of Water for Coal Supercritical Water Gasification System

Study on the Lower Flammability Limit of H-2/Co in O-2/H2o Environment

Measurements of Coefficient of Convective Heat Transfer for Endothermic Hydrocarbon Fuel Up to Supercritical Pressures

Experimental Study on Density Measurement of Endothermic Hydrocarbon Fuels under High Pressure and Low Temperature

Anomalous Enhancement of Heat Transfer to H2O/CO2 Mixtures in Near-Critical Region