Application of Spectroscopic in the Study of Milk Fat in Dairy Cream
Wang Yun-na,Li Yan,Li Yang,Yin Wei-hua,Zhang Lie-bing
DOI: https://doi.org/10.3964/j.issn.1000-0593(2019)06-1773-06
2019-01-01
Spectroscopy and spectral analysis
Abstract:Milk fat is the main raw constituent of dairy cream. The source of the milk has a significant influence on its physicochemical properties and the presence of the dispersed phase in the emulsion, which, in turn, influences the quality of cream products. In this paper, Raman spectroscopy combined with dynamic light scattering, near infrared spectrum-stability analysis, and other spectroscopy techniques were used to study the physiochemical characteristics of milk fat from three different sources, namely MF-A, MF-B and MF-C, and to compare the corresponding stability of dairy cream The Raman spectra results indicated that 1303 and 1446 cm(-1) were -CH2 vibrations, 2800 similar to 3000 cm(-1) was a C-H vibration, and 1131 cm(-1) was a C-C vibration, ith a peak intensity of MF-A>MF-B>MF-C (p<0.05). These results established that MF-A had the highest degree of saturation. 1 657 cm(-1) was a C=C cis-stretching vibration, thus indicating that all samples contained cis-unsaturated fatty acids and had no trans-fatty acids. The peak intensity was MF-C> MF-B> MF-A (p<0.5), indicating that MF-C had the highest cis-unsaturated fatty acid content. Iodine analysis further showed that MF-A had the highest degree of saturation. Solid fat content (SFC) at different temperatures showed MF-A>MF-BUMF-C (p<0.05) in the heat range of 0 similar to 40 degrees C. Therefore, dairy cream should be stored at around 4 degrees C and whipped cream at between 10 and 15 degrees C. After isothermal crystallization at 25 degrees C for 1 h, the three samples were observed under a polarized light microscope: MF-A, which had a low iodine value and a high melting point, formed the nucleus quickly and induced the surrounding fat to crystallize continuously until aggregated to form a dense crystalline network; MF-B exhibited a combination of spherulites and needle-like crystals, and the crystal network was incomplete; MF-C crystals were sparsely distributed with the diameter of each crystal less than 20 mu m. Subsequently, dairy creams XMF-A, XMF-B and XMF-C were prepared using MF-A, MF-B and MF-C, respectively. As can be seen in the particle size distribution chart, XMF-A is basically unimodal, suggesting that the cream emulsion was relatively stable and the fat globules were not coalesced. Both XMF-B and XMF-C are bimodal, suggesting partial coalescence of the fat globules, with XMF-C's degree of coalescence greater than that of XMF-B, providing XMF-C with the largest average particle size. The dynamic light scattering results recorded the average particle size of milk fat globules as follows: XMF-A<XMF-B<XMF-C[(2.22 +/- 10.05), (1.81 +/- 0.04), (1.92 +/- 0.03) mu m] (p<0.05). The near infrared transmission map showed that the transmission of XMF-A and its variable range were relatively small, signifying that there was no obvious serum loss or flocculation in the cream system. Both XMF-B and XMF-C had a relatively high transmission, especially XMF-C which had a narrow and sharp transmission area, indicating instability during the centrifugation process, in which severe lactation, fat floating and opacity were apparent. The space stability of the system was recorded as XMF-A>XMF-B>XMF-C (p<0.05). The results of this research, which examines the physicochemical properties of milk fats in their continuous/dispersive phase and the mechanism of milk fat composition and crystallization behavior on dairy cream quality, thus provide a theoretical basis for the selection of raw materials in the preparation of a variety of dairy products.