Abstract:Urea thermolysis and isocyanic acid hydrolysis over three kinds of zeolites are investigated experimentally and the main decomposition products, NH3 and HNCO, are focused on. The results gained using thermogravimetric analysis with heating rates of 2 degrees C/min from 50-500 degrees C show NH3 releases mainly in 133-250 degrees C and the main thermal product above 250 degrees C is HNC. NH3 release process appears double-peaked while HNCO triple-peaked. Zeolites shift urea decomposition to lower temperature and shorten the process. The experiments of urea thermolysis over zeolites were done in the fixed reactor at programmed temperature and constant temperature. Although zeolites enhance the production of both NH3 and HNCO, the yield ratio of NH3 increases to 1.1 from 0.9 when adding zeolites but the yield ratio of HNCO is always below 0.8. Under zeolites's catalytic effect, the peak of NH3 release and the second peak of HNCO release become stronger. Moreover, zeolites can result in the HNCO peaks integrating into a stronger peak at 500 degrees C. The total yield of NH3 and HNCO increases about 0.1-0.2 with zeolites and the catalytic effect is more obvious at low temperature. In the experiment of thermolysis with a urea-water spray, over 96% urea could decompose to NH3 and HNCO when the temperature is over 550 degrees C and the residence time is more than 1.0 s. Zeolites show good catalytic performance on HNCO hydrolysis to NH3 and the conversion of HNCO to NH3 increases with increasing temperature and reaches above 80% at 250 degrees C and can touch 100%. The catalytic effect on urea thermolysis and HNCO hydrolysis decreases in the order H-Y > H-beta > H-ZSMS, which might be due to the amount of acidic sites on the catalysts. The apparent activation energy of the hydrolysis reaction is so low that the overall hydrolysis reaction rate on catalysts is mainly determined by external and internal mass-transfer limitations.

Temperature Programmed Desorption and Thermal-Decomposition of N-Butylamine on Zeolite Hzsm-5

Synthesis of N, N-dimethyl-n-butylamine with Tubular Reactor

Temperature-Programmed Desorption of Pyridine on Zeolites in the Presence of Liquid Solvents

Environmentally Benign Alcoholysis of Urea and Disubstituted Urea to Alkyl Carbamates over Alkali-Treated Zeolites

Simulation Of Nh3 Temperature-Programmed Desorption Curves Using An Ab Initio Force Field

30-P-07-degradation of N-nitrosamines on Zeolites

Effects of post treatment of HZSM-5 zeolites on catalytic cracking of butene

Catalytic Performance of Zeolites on Urea Thermolysis and Isocyanic Acid Hydrolysis

Acidity Characterization of Hzsm-35 Zeolite by Solid-State Nmr

Characterization of Acidic Properties of AgNaZSM-5 Catalyst

Temperature programmed surface reaction of N′-nitrosonornicotine on zeolites and molecular sieves

Influence of Channel, Construction and Brønsted Acid Sites on the Catalytic Conversion Pathways of Isobutane over MFI, TON and RFE Zeolites

Adsorption and Decomposition of N-nitrosamines on Zeolites

Investigation on Catalytic Decomposition of N-Nitrosamines over Zeolites

Postsynthesis of Mesoporous ZSM-5 Zeolites with TPAOH-assisted Desilication and Determination of Activity Performance in N 2 O Decomposition

Adsorption and Room Temperature Degradation of N-nitrosodiphenylamine on Zeolites

Temperature‐Induced Modifications in Natural Zeolite Clinoptilolite: Effects on Acidity and Catalytic Acetalization

Study of deamination of ethylenediamine to piperazine on ZSM-5 zeolite catalysts

Adsorption of Water and Methanol on a NaZSM-5 Zeolite. A temperature-programmed desorption (TPD) study

Temperature-Programmed Surface Reaction of Butadiene on Molybdenum Nitride Catalyst

Impact of Heating Rate on Desorption Performance of CO2 Attached to 13X Zeolite