Abstract:Up to now, little research of water dynamic about circulating fluidized bed boiler with water-cooled square cyclone has been carried out; which limits the scaling up of CFB boilers. In this paper, two methods to calculate the water dynamic are proposed. One bases on the traditional water dynamic calculation to compile Microsoft Excel calculation sheet. The flow rate of different membrane wall sections is adjusted following principle that the pressure drops are same. In another method, the corresponding pressure drops of each membrane wall section under three different flow rates are calculated by the Excel sheet. The flow rate characteristics of each section are represented approximately by the conic curves drawn out from the excel results. The pressure characteristic curves of the furnace are described and drawn out by coupling all conics in series or in parallel. The working point is calculated based on the riser and downcomer system. Through the total flow rate characteristics curve, it is easy to analyze the influence of some parameters on the water dynamics, such as the flow rate, pipe geometry, and the membrane wall temperature. This is helpful for accumulating the experience of the water dynamic calculation. The coupling of the membrane wall sections arranged in series and in parallel is discussed for complex water circulation. When there is no probability for coupling, simplified assumptions are made to make the coupling possible. Also a Matlab procedure is used for coupling, which makes it convenient to find out the working point. In addition, a safety confirmation analysis besides the water dynamic calculation of a 130 t/h high pressure CFB produced by Sichuan Boiler Plant is performed. The safety problems of the boiler and the relevant structure problems are found through the calculation. Some experiences of water dynamic calculation are accumulated from this work, and also some foundation of the water dynamic calculation is built for scaling up of CFB boiler.

The Water Dynamic Safety Of Cfb Boiler With Water Cooled Square Cyclone

The Study of Unified Thermal Calculation Model of Circulating Fluidized Bed Boiler Based on Experience

The hydrodynamic characteristics of embattlement shaped water wall of a 350 mw supercritical circulating fluidized bed boiler

Research on Waterwall Dynamic Characteristics of a 600 MW Supercritical Circulating Fluidized Bed Boiler

Thermal-Hydraulic Calculation and Analysis on Water Wall System of 600 Mw Supercritical Cfb Boiler

Thermal–hydraulic Calculation and Analysis of a 600 MW Supercritical Circulating Fluidized Bed Boiler with Annular Furnace

Thermal–Hydraulic Calculation and Analysis on Water Wall System of a 700 MWe Ultra-Supercritical CFB Boiler

Thermal-hydraulic analysis of a 600 MW supercritical CFB boiler with low mass flux

Dynamic Modeling and Simulation of CFB Boiler

Research on the Hydraulic Characteristics of a 600MW Supercritical Pressure CFB Boiler

Development and validation of a dynamic flowsheet model for a 350 MWe supercritical circulating fluidized bed boiler

Structure and Performance of a 600MWe Supercritical CFB Boiler with Water Cooled Panels

THERMAL CALCULATION OF A CIRCULATING FLUIDIZED BED BOILER FURNACE

Heat Flux Distribution on Circulating Fluidized Bed Boiler Water Wall

Research on the Water Wall Design and Hydrodynamic Characteristics of a 600 MW Supercritical Pressure CFB Boiler

An Experimental Study on the Hydrodynamic Performance of the Water-Wall System of a 600 MW Supercritical CFB Boiler

Study on Dynamic Behavior of the Combustion System of a Circulating Fluidized Bed Boiler

Heat transfer characteristic of water wall and partition wall in a 600 MW CFB boiler

Calculation and Analysis of Heat Transfer Coefficients in a Circulating Fluidized Bed Boiler Furnace

STUDY ON DYNAMIC MATHEMATICAL MODEL AND SIMULATION OF CFB BOILER

Steam Temperature Characteristics in Boiler Water Wall Tubes Based on Furnace CFD and Hydrodynamic Coupling Model