Abstract:In this study, we revisit the oxidation reactions of a single-crystal silicon wafer and compare the reported crystal structures of the formed oxides with the original diamond structure of single-crystal silicon. It is commonly assumed that interstitial silicon atoms are always emitted during oxidation at the reactive interface between silicon and the formed oxide due to volume differences. However, it is important to acknowledge that this phenomenon may not always be observed. Thermal equilibrium studies have revealed that a certain percentage of silicon atoms in the diamond structure remains even after surface oxidation [Kamiyama and Sueoka, J. Appl. Phys. 134, 115301 (2023)]. These retained silicon atoms undergo a transformation into a different crystal structure, presenting as β-cristobalite (space group: P41212) rather than the anticipated non-ideal cristobalite (space group: Fd-3m). Our ab initio calculations indicated that the latter remains stable next to a quartz-based structure, exhibiting optimal compatibility with the Si (001) surface. This quartz-based structure is formed through the emission of a Si atom during the oxidation of single-crystal silicon, finally forming a quartz/Si (001) interface. Therefore, we propose a coexisting model involving an alternative β-cristobalite and a quartz crystal structure originating from the surface oxidation of single-crystal silicon. This model offers an explanation for why thermally oxidized films derived from single-crystal silicon exhibit an amorphous nature. In addition, studies have revealed that the oxide precipitates observed in Si crystals are cristobalite and coesite. Hence, the qualitative differences in SiO2/Si interfaces between surface and internal oxidations in metal-gettering effectivity shown in experimental literature require clarification. We also discuss the conditions that prevent the emission of Si atoms.

Substrate-dependent structural evolution during the oxidation of SiNx thin films

Abnormal oxidation in nickel silicide and nickel germanosilicide in sub-micro CMOS

Microstructure and oxidation behavior of SiOC coatings on C/C composites co-deposited with HMDS and TEOS by using CVD process

New Design Concept for Stable Α-Silicon Nitride Based on the Initial Oxidation Evolution at the Atomic and Molecular Levels

Deposition of SiOxNy films as gate insulator via r.f. reactive sputtering

Oxidation Behaviour of NiSi-NiCr Thin Film Thermocouples and Antioxidation Effect of SiNxOy Film

Evolutions and distributions of Si nanocrystals and other Si oxidation states in Si-implanted SiO2 films

Substrate suppression of oxidation process in pnictogen monolayers

Stability of SiNx Prepared by Plasma-Enhanced Chemical Vapor Deposition at Low Temperature

Effect of oxidation on crack propagation of Si nanofilm: A ReaxFF molecular dynamics simulation study

Thermal Oxidation of WSe2 Nano-sheets Adhered on SiO2/Si Substrates

Improved Thermal Stability and Oxygen‐Barrier Performance of SiO2 Thin Films by Modifying Amorphous Network Structure

Controlled fabrication of Si nanocrystals embedded in thin SiON layers by PPECVD followed by oxidizing annealing

Oxidation simulation study of silicon carbide nanowires: A carbon-rich interface state

The cyclic and continuous oxidation of Si3N4 with and without aluminum implantation

Revisiting single-crystal silicon oxidation: A comprehensive analysis of crystal structural transformation to SiO2

Initial stage oxidation on nano-trenched Si(1 0 0) surface

Reliable Simulation Analysis of Interface and SiON Degradation Effects on Water Vapor Barrier in Laminated Thin‐Film Encapsulation

Crystallization and Oxidation Behaviors of Cr-Si-Ni-N Resistive Films

Effect of Interface on Oxidation Behavior and Tribological Properties of CrAlN/SiNx Multilayer Films

Thermal Oxidation of WSe 2 Nanosheets Adhered on SiO 2 /Si Substrates