Abstract:As one selection of the fourth-generation reactors, the gas cooled reactor has received enormous attention such as high power conversion efficiency and simple cycle layout. In this paper, the flow mixing and heat transfer characteristics of supercritical carbon dioxide within a seven-pin wire-wrapped bundle were investigated. Due to the lack of more experiments data of velocity field, two experiments were selected to validate the uncertainty of different turbulence models from the view of temperature field. The analysis of mass exchange between different subchannels revealed that coolant flows consistently in a certain direction in edge and corner subchannels, whereas in center subchannels, the cross flow changes direction periodically. The mixing coefficients at three types of subchannel interfaces were fitted by a sine function with the R2 values are all greater than 0.96. For different mass flux and pressures, the root mean square error between correlations and simulations was less than 1 × 10-3, except when Re equals 15000. Additionally, the heat transfer deterioration of SCO2 was observed. While wire spacers can mitigate the extent of heat transfer deterioration, they cannot completely eliminate it. The Performance Evaluation Criterion (PEC) was introduced to assess the effectiveness of wire spacers in enhancing heat transfer. The results indicate that the PEC exceed unity, meaning that the enhanced heat transfer capability outweighs the additional resistance loss caused by wire spacers. With increasing pressure, the PEC decreases but remains greater than unity. The mixing of coolant between different subchannel induced by wire spacers can reduce the wall temperature of rods at the edge of the bundle. However, the seven-pin wire-wrapped bundle was investigated in this work, and the results may not accurately reflect the flow and heat transfer inside a real reactor rod bundle. In the future, a larger scale rod bundle should be conducted to obtain more universally applicable and realistic flow and heat transfer phenomenon for reactor assembly design.

An Experimental investigation of void fraction characteristics of Flow Boiling in a 5×5 rod bundle channel

Two-phase Flow Oscillation and Distribution in Parallel Channels During R1233zd(E) Subcooled Flow Boiling: A Numerical Study

Theoretical and Experimental Research on Flow Boiling Heat Transfer in Microchannels for IGBT Modules

Experimental study of two-phase parameters of subcooled boiling flow in a single-side heated rectangular channel

Experimental Study of Flow Boiling Instabilities in Horizontal Tubes under Gas–liquid Stratification Condition: Effects of Heat Flux and Inlet Subcooling Degree

Experimental and Numerical Investigation of Sub-Cooled Boiling, Condensation, and Void Flashing in Nuclear Heating Reactor Test Loop

Flow characteristics of dispersed two-phase flows in an 8 × 8 rod bundle

Research on void drift between rod bundle subchannels

A Unifying Bubble-Layer-Based Theoretical Model for Flow Boiling and Application to a Rod Bundle

Flow mixing and heat transfer deterioration investigation of supercritical carbon dioxide in wire-wrapped bundles

Experimental investigation of local boron concentration in a 2 × 2 rod bundle channel under subcooled boiling flow

3-D numerical study of subcooled flow boiling in a horizontal rectangular mini-channel by VOSET

Experimental Study on Local Subcooled Flow Boiling Heat Transfer in A Vertical Mini-Gap Channel

Flow boiling heat transfer and pressure fluctuation characteristics in a divergent channel with inclined downward-facing heater

Local Heat Transfer in Subcooled Flow Boiling in a Vertical Mini-Gap Channel

Numerical simulation of boiling behavior in vertical microchannels

Effects of Heat Flux, Mass Flux, Inlet Fluid Subcooling, and Channel Orientation on Subcooled Flow Boiling in a High-Aspect-Ratio Rectangular Microchannel

Numerical Investigation of Flow Boiling Characteristics in Narrow Rectangular Channels Using Two-Fluid Eulerian Cfd Model Covering a Wide Range of Pressures

Local Heat Transfer of Saturated Flow Boiling in Vertical Narrow Microchannel

Numerical investigation of critical heat flux during subcooled flow boiling in a vertical rectangular Mini-channel

Experimental Study Of Saturated Flow Boiling In Vertical Narrow Microchannel