Abstract:A novel plasma-driven catalysis (PDC) reactor with special structure was proposed to remove vehicle exhaust gas. The PDC reactor which consisted of three quartz tubes and two copper electrodes was a coaxial dielectric barrier discharge (DBD) reactor. The inner and outer electrodes firmly surrounded the outer surface of the corresponding dielectric barrier layer in a spiral way, respectively. Nano-titanium dioxide (TiO2) film prepared by radiofrequency (RF) magnetron sputtering was coated on the outer wall of the middle quartz tube, separating the catalyst from the high voltage electrode. The spiral electrodes were designed to avoid overheating of microdischarges inside the PDC reactor. Continuous operation tests indicated that stable performance without deterioration of catalytic activity could last for more than 25 h. To verify the effectiveness of the PDC reactor, a non-thermal plasma(NTP) reactor was employed, which has the same structure as the PDC reactor but without the catalyst. The real vehicle exhaust gas was introduced into the PDC reactor and NTP reactor, respectively. After the treatment, compared with the result from NTP, the concentration of HC in the vehicle exhaust gas treated by PDC reactor reduced far more obviously while that of NO decreased only a little. Moreover, this result was explained through optical emission spectrum. The O emission lines can be observed between 870 nm and 960 nm for wavelength in PDC reactor. Together with previous studies, it could be hypothesized that O derived from catalytically O-3 destruction by catalyst might make a significant contribution to the much higher HC removal efficiency by PDC reactor. A series of complex chemical reactions caused by the multi-components mixture in real vehicle exhaust reduced NO removal efficiency. A controllable system with a real-time feedback module for the PDC reactor was proposed to further improve the ability of removing real vehicle exhaust gas.

Double dielectric barrier discharge device with catalytic coating for waste gas treatment

A two dielectric barrier discharge devices for exhaust -gas treatment has a catalytic coating

Characteristics of Back Corona Discharge in a Honeycomb Catalyst and Its Application for Treatment of Volatile Organic Compounds.

Highly efficient treatment of textile dyeing sludge by CO 2 thermal plasma gasification.

Dielectric Barrier Discharge Assisted by Wire Mesh in a Gas-liquid Two-phase Mixture and Its Application to Water Treatment

Reactor for DC corona discharge free radical shower flue gas treatment

Application of Non-Thermal Plasma Technology on Fugitive Methane Destruction: Configuration and Optimization of Double Dielectric Barrier Discharge Reactor

Dielectric Barrier Discharge Plasma Coupled with Catalysis for Organic Wastewater Treatment: A Review

Volatile Organic Compounds (vocs) Removal in Non-Thermal Plasma Double Dielectric Barrier Discharge Reactor

Self-holding wide-temperature high-sealing performance dust removal device and process

Study of double-chamber air arc plasma torch and the application in solid-waste disposal

Integrated system for deeply removing various pollutants

Novel Multineedle-to-cylinder Plasma Coupled with Bimetallic Catalysts for Efficient Removal of Sulfides and Ammonia in Odor Gases

Dual-course Dielectric Barrier Discharge with a Novel Hollow Micro-Holes Electrode to Efficiently Mitigate NOx

Vehicle Exhaust Gas Clearance By Low Temperature Plasma-Driven Nano-Titanium Dioxide Film Prepared By Radiofrequency Magnetron Sputtering

Catalyzing Industrial Wastes Through Discharge Plasma for Diesel Exhaust Cleaning: A Case Study with Cascaded Corona Reactors

Side-by-side double-fluidized bed chemical-looping combustion/gasification device coupled with jacket type carbon separator

System for removing pollutants while discharging, condensing and collecting water

Dual-course dielectric barrier discharge with a novel hollow micro-holes electrode to efficiently mitigate NO x

Double dielectric barrier discharge incorporated with CeO2-Co3O4/γ-Al2O3 catalyst for toluene abatement by a sequential adsorption–discharge plasma catalytic process

Degradation of chlorinated volatile organic compounds in waste gas by catalytic plasma system