Abstract:Walnut green husk extract(WGHE) was prepared by reflux method using forestry and agricultural residue of walnut green husk as the raw materials. The synergistic inhibition effect of WGHE and the anionic surfactant of sodium dodecyl benzene sulfonate(SDBS) on the corrosion of cold rolled steel(CRS) in citric acid(H3C6H5O7) solution was studied by weight loss, potentiodynamic polarization curves, electrochemical impedance spectroscopy(EIS) and scanning electron microscope(SEM). The results show that individual WGHE or SDBS can retard the corrosion of CRS surface in 1.0 mol/L H3C6H5O7 solution to some extent. However, the maximum inhibition efficiency is below 60% for either individual WGHE or SDBS. Incorporation of WGHE with SDBS can obtain efficient inhibitive action, and the maximum inhibition efficiency can reach as high as 94.2%. All synergism parameters are higher than 1, and so there is a true synergistic inhibition effect between WGHE and SDBS. The synergistic inhibition increases with an increase of WGHE concentration, while decreases with an increase of temperature, and reaches a peak value with the acid concentration of 1.0 mol/L and the immersion time of 72 h. No matter whether WGHE is mixed with SDBS, the adsorption behavior on steel surface obeys Langmuir adsorption isotherm. The adsorption equilibrium constant of WGHE/SDBS mixture is increased evidently comparing with individual WGHE or SDBS. WGHE/SDBS is a mixed-type inhibitor, which shifts both cathodic and anodic branches to negative corrosion current densities. EIS has only one time constant, and its Nyquist spectrum exhibits a depressed capacitive loop. The charge transfer resistance of steel/solution interface follows the order: WGHE/SDBS > WGHE > SDBS. SEM and AFM micrographs confirm that WGHE/SLS can efficiently alleviate the corrosion degree of steel surface in citric acid media, and the surface roughness is significantly dropped. There is a synergism between SDBS and the major components of rutin, quercetin, 1-methylnaphoqinone and juglone in WGHE, but their synergistic inhibition is below than the mixture of WGHE/SDBS.

Theoretical (atomic-DFT&molecular-MD), surface/electrochemical investigations of walnut fruit green husk extract as effective-biodegradable corrosion mitigating materials of a steel electrode in 1M HCl electrolyte

Theoretical and surface/electrochemical investigations of walnut fruit green husk extract as effective inhibitor for mild-steel corrosion in 1M HCl electrolyte

A new study on the corrosion inhibition mechanism of green walnut husk extract as an agricultural waste for steel protection in HCl solution

Electrochemical and DFT studies of Terminalia bellerica fruit extract as an eco-friendly inhibitor for the corrosion of steel

Combined atomic-scale/DFT-theoretical simulations & electrochemical assessments of the chamomile flower extract as a green corrosion inhibitor for mild steel in HCl solution

MD Simulation/quantum Chemical Calculations and Experimental Studies of Ranunculus Bulbosus Biomolecules Impact on the Mild Steel Dissolution Reduction in a Destructive Acidic Liquid

Experimental and Quantum Chemical Studies of a Green Corrosion Inhibitor for Mild Steel in Acidic Chloride Solution

Exploration of Walnut Green Husk Extract As a Renewable Biomass Source to Develop Highly Effective Corrosion Inhibitors for Magnesium Alloys in Sodium Chloride Solution: Integrated Experimental and Theoretical Studies

Experimental and computational aspects of green corrosion inhibition for low carbon steel in HCl environment using extract of Chamaerops humilis fruit waste

Synergistic inhibition effect of walnut green husk extract and potassium iodide on the corrosion of cold rolled steel in trichloroacetic acid solution

Enhancement Corrosion Resistance of Mild Steel in 15% HCl Solution by a Novel Bio-Based Polyurethane for Oil Well Acidizing

The effect of the Oğuzlar walnut extract as a green corrosion inhibitor on AISI 1010 mild steel

Application of Green Active Bio-Molecules from the Aquatic Extract of Mint Leaves for Steel Corrosion Control in Hydrochloric Acid (1M) Solution: Surface, Electrochemical, and Theoretical Explorations

Development of Natural Plant Extracts as Sustainable Inhibitors for Efficient Protection of Mild Steel: Experimental and First-Principles Multi-Level Computational Methods

Modification and Application of Walnut Peel Extract as Acidic Corrosion Inhibitor

Bio-based ionic liquid as a corrosion inhibitor for mild steel in 5% HCl solution: Experimental and theoretical investigation

Imidazolium-Based Polymeric Ionic Liquids with Short Alkyl Chains As Green Corrosion Inhibitors for Mild Steel in 1 M HCl: Experimental and Theoretical Investigations.

Alkaloid extract of seed Citrullus colocynthis as novel green inhibitor for mild steel corrosion in one molar HCl acid solution: DFT and MC/MD approaches

Preparation of corrosion inhibitor from natural plant for mild stil immersed in an acidic environmental: experimental and theoretical study

Corrosion Inhibition, Surface Adsorption and Computational Studies of Momordica Charantia Extract: a Sustainable and Green Approach

Synergistic Effect of Walnut Green Husk Extract Complex Inhibitors on Steel in Citric Acid