Abstract:While microalgae are promising biomass candidates for biodiesel production, efficient lipid extraction is hindered by the strong cell walls. Cell wall disruption is an essential processing step for improving lipid yields from microalgae biomass. Conventional methods use toxic organic solvents (e.g., mixtures of chloroform and methanol or hexane) to extract microalgal lipids. This study with Chlorella pyrenoidosa investigates a novel microalgal pretreatment by a deep eutectic solvent (choline chloride:acetic acid) to increase cell wall disruption prior to lipid extraction. Deep eutectic solvent and ultrasonic homogenization should be best performed after 5 min of pretreatment. Biomass was characterized before and after the pretreatment to understand the mechanism. To optimize the lipid extraction yield, the effect of various variables (methanol to n-butanol, solvent to biomass ratio, time, and temperature) on lipid extraction yield was investigated using a single-factor experiment. The maximum lipid yield (19.25%) was extracted at 1:4 methanol to n-butanol and a 30 (v/w) solvent to biomass ratio over 120 min at 60 °C. Fatty acid methyl esters were obtained through transesterification reactions from extracted lipid of optimized condition and biodiesel quality was studied in comparison with European and US standards. The dominant fatty acids were C16:0 (29.54%), C18:2 (18.42%), and C18:3 (19.50%) and properties of biodiesel are within the European and US standards. This novel pretreatment method, coupled with lipid yields and characterization, documents the significant potential for microalgae biodiesel as an alternative, sustainable energy source.

Physicochemical Characterizations of Microalgal Methyl Esters Extracted with Hexane and Refined by Vacuum Distillation at Different Temperatures

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Vacuum distillation of C16 methylester and C18 methylester in biodiesel

Using Renewable Ethanol and Isopropanol for Lipid Transesterification in Wet Microalgae Cells to Produce Biodiesel with Low Crystallization Temperature

Mild Hydrothermal Treatment on Microalgal Biomass in Batch Reactors for Lipids Hydrolysis and Solvent-Free Extraction to Produce Biodiesel

Microalgae biomass pre-treatment with deep eutectic solvent to optimize lipid isolation in biodiesel production

Biodiesel from wet microalgae: extraction with hexane after the microwave-assisted transesterification of lipids.

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Efficient Biodiesel Conversion From Microalgae Oil Of Schizochytrium Sp.

Ultrafiltration of Triglyceride from Biodiesel Using the Phase Diagram of Oil–fame–meoh

Using wet microalgae for direct biodiesel production via microwave irradiation

Mixing Food Waste and Microalgae to Simultaneously Improve Biodiesel Production Through Transesterification and Bio-Crude Production Through Hydrothermal Liquefaction

High Quality Biodiesel Production from a Microalga Chlorella Protothecoides by Heterotrophic Growth in Fermenters

STUDY ON PREPARATION OF BIODIESEL FROM MICROALGAL OIL

Rapid extraction of lipid from wet microalgae biomass by a novel buoyant beads and ultrasound assisted solvent extraction method

Efficient fractionation of microalgae biomass as a whole for biodiesel production enabled by deep eutectic solvent and water

Extraction of microalgae oil and further production for second-generation biodiesel

Biodiesel Production from Heterotrophic Microalgal Oil.

A Novel Process on Lipid Extraction from Microalgae for Biodiesel Production

Enzymatic Transesterification of Yeast Oil for Biodiesel Fuel Production

Solvent-free Lipid Extraction from Microalgal Biomass with Subcritical Water in a Continuous Flow Reactor for Acid-Catalyzed Biodiesel Production