Abstract:<p>The increase of liquid saturation badly affects the fluidization dynamics, even resulting in the failure of fluidization. Nevertheless, few researches focus on characterizing the flow pattern transition of wet particles. In this work, we discuss the effects of the liquid saturation, gas velocity and the particle size on the global fluidization dynamics of Geldart D particles by analyzing the pressure fluctuations in the fluidized bed. The results show that the bubble dynamics is intensified with the increasing liquid saturation and decreasing particle size. When the superficial gas velocity increases, the fluidization regimes change from expanding regime, to multi-bubbling regime and slugging. During the normal fluidization and slugging, the liquid bridge forces prevent the growth of large bubbles and promote the probability of bubble break-up. Thus, the average bubble size decreases and the number of bubbles increases, which lead to the intense bubble behavior. With the decreasing particle size, the effect of liquid bridge forces is enhanced, contributing to the intensified bubble dynamics, including fast rising, frequent coalescence and eruption of a large number of bubbles. Compared to dry particles, wet particles are easily to cause defluidization when the gas velocity is small. The PSD patterns have the sharp narrow peaks at frequency lower than 0.8 Hz. When the liquid saturation is increased to 30%, a gas channel forms in the bed, which resists the normal works of the fluidized bed. Basically, reducing the liquid saturation is a reasonable way to avoid defluidization.</p>

Experimental study on vibrating fluidization characteristics of wet particles

Wavelets Analysis of Pressure Fluctuation in Agitated Fluidized Bed

Effect of Agitation on the Fluidization Behavior of a Gas–solid Fluidized Bed with a Frame Impeller

Experimental Investigation of Bubble and Particle Motion Behaviors in A Gas-Solid Fluidized Bed with Side Wall Liquid Spray

CFD Simulation of an Agitated Gas-Fluidized Bed: Effects of Particle–particle Restitution Coefficient on the Hydrodynamics

Numerical simulation of pressure fluctuation in gas-solids agitated fluidized bed

Evolution and Fluidization Behaviors of Wet Agglomerates Based on Formation-Fragmentation Competition Mechanism

Experimental Investigation of Electrostatic Effect on Particle Motions in Gas-Solid Fluidized Beds

Particle Fluidization Characteristics and Transition in a Hot Gas-Solid Fluidized Bed with Liquid Injection

Characterization of Flow Pattern of Cohesive Particles in Gas-Solid Fluidized Bed Via Axial Distribution of Particle Motions

Experimental and Modeling Investigation of Liquid-Induced Agglomeration in a Gas–Solid Fluidized Bed with Liquid Spray

Heat Transfer of Batch Simulating Continuous Fluidized Bed with Wet Particles

Experimental investigation of wet particle flow characteristics in a pseudo two-dimensional fluidized bed

Parametric study of fine particle fluidization under mechanical vibration

Fluidization of fine powder assisted by vertical vibration in fluidized bed reactor

Vibro-fluidization of cohesive particles

Effects of Interparticle Forces on Fluidization Characteristics in Liquid-Containing and High-Temperature Fluidized Beds

A Numerical Study on Gas-Fluidized Beds of Wet Flexible Fibers

Fluidization characteristics of loaded vibrating fluidized bed and dewatering and deashing effect of moist fine-grained coal

Fluidization dynamics of wet Geldart D particles by pressure fluctuation analysis

Numerical Study of Particle Injection into a Gas-Solid Fluidized Bed