Effects of Structurants on Structure and Loading Capacity of Ternary Organogels

Guo-qin LIU,Wen-bo WAN

DOI: https://doi.org/10.3969/j.issn.1000-565X.2016.10.021

2016-01-01

Abstract:Ternary curcumin-organogels were prepared based on corn oil and by using sitosterol + letithin,ceramide,ethyecellulose as thestructurants.Then,the effects of the structurants on the macroscopic properties (the rheological behaviors,the solid fat content,etc) and the microscopic properties (the microstructures,the crystalline structure,etc) of ternary organogels were discussed,and the corresponding loading capacities were also evaluated.Experimental results show that (1) the structures of sitosterol + letithin-organogels and ceramideorganogels are similar and are both fibrous crystal structure,and the former exhibits a tighter network with higher encapsulation efficiency (EE) and loading capacity (LC),which are respectively (3.14 ± 0.10) mg/g and (62.78 ± 2.01)％;(2) however,the structure of ethyecellulose-organogelsis totally different from the above two structures,and it is granular with a smaller crystal and relatively loose network;and (3) because of higher preparation temperature,ethyecellulose-organogels show the highest load level,specifically,LC and EE are respectively (4.810 ± 0.174)mg/g and (96.19 ± 3.48)％.The above results indicate that the structurants significantly affect the properties,microstructures and loading capacity of organogels.