The Combustion Cycle Fluctuation Analysis of Premixed Methanol Charge Induced by F-T Diesel

Zhen-yu GE,Jian-jun ZHU,Tie WANG

DOI: https://doi.org/10.3969/j.issn.1671-1815.2016.03.011

2016-01-01

Abstract:Effects of engine speed , load and energy substitution ratio of methanol on combustion cycle-to-cycle fluctuation were studied experimentally in a premixed charge induced ignition combustion diesel engine .In the re-search, the combustion modes , in which the energy substitution ratio of methanol were 5%, 10%and 15%respec-tively , were compared with the original combustion mode of 0#Diesel .Results show that when increasing the en-gine speed the engine output power fluctuation change little , while the specific the combustion process change a lot with the speed increasing , whose peak value of heat release rate ( HRR) fluctuation rate reach as high as 25%;the cyclic fluctuation of the engine is small under moderate load , but large when the engine running at small load con-ditions like starting and idling , the max HRR peak value fluctuation rate reached 30%, the start of combustion fluctuation rates are always greater than 10%both at very large and small load;the cyclic fluctuation of the com-bustion mode is slightly large when methanol energy alternative in the low proportion , however , when methanol ratio increases to a certain value the cyclic fluctuation gradually reduced to the level of 0#diesel engine , or even lower .