Abstract:Abstract Abnormal discontinuous low-frequency noise occurs in the outdoor unit when the air conditioner is operating at 86~96 Hz. This noise has the characteristics of low frequency, strong penetration, long transmission distance, and poor sound quality, which can cause serious noise pollution. In order to reduce the low-frequency noise of the outdoor unit of the air conditioner, the discontinuous noise frequency is first located by testing the time-domain and frequency-domain maps of the noise. It is then compared with the frequency of fan rotation noise and structural radiation noise. It is found that the discontinuous noise is caused by the coupling of fan rotation noise and structural radiation noise. It is found that low-frequency noise improvement is significant when the frequency difference between two noise peaks is greater than 8 Hz or when a single noise peak is less than 25 dB(A) by studying the methods of frequency modulation and amplitude modulation of noise peaks. By adjusting the fan speed from 930 rpm to 940 rpm, the problem of 94 Hz noise is solved. Then, through testing the natural frequencies of the pipe and shell, it is found that the natural frequencies of the pipe are close to the excitation frequencies. The structural radiation noise is mainly caused by the pipe. Modal analysis is conducted on the pipe. When the normal boundary with the condenser and the normal boundary with the valve of the pipe is constrained by springs, the simulated values are closer to the measured values. Finally, structural optimization design is carried out on the pipe. When the U-tube of the exhaust pipe is shortened by 30 mm, a 30 g mass block is added to the cold inlet pipe, and a 97 g mass block is added to the lower part of the valve pipe of the suction pipe. The discontinuous noise of the optimized prototype is significantly improved.

The study of transmission abnormal noise when the air conditioning idles in a vehicle

A Study on the Noise and Vibration Testing System for Automotive Final Drive

Research on Refrigerant Flow Noise under Sudden Stop of Automobile Air Conditioning

Research on Mechanism Diagnosis of an Idling Abnormal Noise of Automobile Engine

Experimental study on gear whine noise from transmission in vehicle

Correlation of the sound quality and vibration of end of line testing for automatic transmission

Study On Adaptive Active Control Of Unstable Noise In Vehicle

Study on Dynamics of Overrunning Spring Clutches and Suppression Methods for Their Abnormal Noise

Study on the influence of sudden load at idle condition on vibration and vibration isolation performance of the engine mount system

Analysis and study of the transmission path based on the body and NVH

Simulation and Experimental Research on Vibration and Noise of Transmission

Analysis and Solution of Abnormal Noise of Throttle Body in Engine

Research on the Active Noise Control Technology for the Reduction of the Air Conditioner Noise in a Vehicle Cabin

Study and Development of Subjective Evaluation of Inner Noise Quality and Improvement

Evaluation and Modeling of Automotive Transmission Whine Noise Quality Based on MFCC and CNN

Dynamic Characteristics of an Automotive Air-Conditioning Electromagnetic Clutch

Research on Interior Noise Control of the Rear Seats in Vehicle

Stochastic Optimization-Based Comparative Study of New Energy Vehicles’ Noise Characteristics

Experimental Study on the Noise Source Identification of a Diesel Engine of Passenger Car

Low-Frequency Discontinuous Noise Diagnosis and Reduction of Air Conditioner Outdoor Unit

Fault Diagnosis Method of Automotive Automatic Transmission