Research on Flow Velocity Field in Jagged Micro-Channel with Micro-PIV

王元,金文,何文博

DOI: https://doi.org/10.3321/j.issn:0253-987x.2009.09.024

2009-01-01

Abstract:With the micro-fluidic particle image velocimetry technique,the flow was measured in both of cusp and fillet jagged micro-channels with a cross section of 800 μm×800 μm at Re=150.Deionized water with 3 μm-diameter fluorescent particles inside was adopted in the micro-channels.The distinct images were obtained with a 10-fold microscope and 14-bit CCD camera system.The influence of Brownian motion was eliminated by averaging obtained images of the particles.Filter lens were used to improve the signal-to-noise ratio of the images.The experimental results indicate that the flow patterns in both jagged micro-channels are similar to each other.There is a low velocity vortex cavity at the swerving inside for both the fillet jagged micro-channel and the cusp jagged micro-channel,and the former vortex cavity is greater than the latter one.Moreover,at the jag peak of the cusp jagged micro-channel,there exist a big intact vortex and a superposition vortex in the opposite direction with lower velocity and unsteady structure.The impure substance in the low-velocity region is easier to deposit and form block,leading to the structure change of the micro-channels.