Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

Calculation Models of Properties of POE/R32 and PVE/R32 and the Properties Analysis

Physical Property Models of R32 and POE and PVE Oil

Models of Thermodynamic and Transport Properties of POE VG68 and R410A/POE VG68 Mixture

Thermophysical Properties of R32/advanced PVE Mixture and Parametric Analysis on Oil Transport Characteristic of Compressor Suction Line

Experimental study on the cycle performance of refrigerant R32

Solubility And Miscibility For The Mixture Of (Ethyl Fluoride Plus Polyol Ester Oil)

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

Study on Flow Boiling Heat Transfer Characteristics of R161/oil Mixture Inside Horizontal Micro-Fin Tube

An experimental investigation and correlation of the viscosity refrigerant/oil solutions

Vapor-liquid Equilibrium Measurement and Heating Performance Modeling on Eco-Friendly Zeotropic Blends of CO2/R1234ze(Z) and CO2/R1336mzz(E)

Experimental Investigation of Oil Retention and Pressure Drop of R32/PVE Oil Mixture in Compressor Suction Line

Modeling of lubricant retention in suction lines with R32/PVE oil mixture

Calculation model and analysis of thermodynamic properties of R32 refrigerant

SIMULATION AND COMPARISON OF AIR-SOURCE HEAT PUMPS USING VARIABLE COMPOSITION AND CONSTANT COMPOSITION MIXTURES OR PURE REFRIGERANT

Calculation and Analysis on Isobaric Specific Heat for Refrigerants

Measurement and Correlation for the Viscosity of R1234yf/POE85 and R1234ze(E)/POE85 Solutions

Experimental Analysis on R290 Solubility and R290/oil Mixture Viscosity in Oil Sump of the Rotary Compressor

Study on the vapor liquid equilibrium of binary-mixture refrigerants CO2/R600

Phase Behavior and Enthalpies of Binary Mixtures of R-1243zf with PAG 68, POE 85 and PEC4 Oils

Modeling of Lubricant Retention in Suction Lines with R32/PVE Oil Mixture Based on Different Flow Patterns

The Performance Analysis of R32 Rotary Compressor Used for Room Air Conditioners