Abstract:Mechanism experiments were performed to investigate NO x formation and reduction during the combustion of high-ash, low-volatile coal. Additionally, industrial-scale trials were conducted to study the effects of air-staging degree on the combustion and NO x emission characteristics of high-ash coal on a 350 MW supercritical down-fired boiler. The results showed that the total BET specific surface area, total pore volume and porosity values of high-ash coal (HAC) and ultra-high-ash coal (UHAC) were all larger than those of normal-ash coal (NAC), whereas NAC contained more N-5 and N-6 than HAC and UHAC. The carbon layer structure of HAC char was less ordered and the content of hydroxyl group was relatively high. The overall NO reduction ratio obtained using the HAC char was higher than the value for the UHAC char. However, in the high temperature range of 1300–1400 °C, NO reduction associated with UHAC char was accelerated because of catalysis by ash. On increasing the excess oxygen ratio λ from 1.0 to 1.2, the char-N conversion shown by the UHAC char slowly increased and remained the lowest among the three chars. When burning UHAC, as the ratio of secondary to tertiary air fluxes, R st , was decreased from 1.56 to 0.57, heating of the fuel-rich coal/air flow slowed and pulverized coal combustion was inhibited. The situation associated with HAC was different. At the R st of 1.11, the ignition distance of fuel-rich flow was the shortest at 1.50 m, and the overall temperature in the furnace was the highest. However the NO x emissions at the furnace exit were as high as 715 mg/m 3 (6 % O 2 ) in this condition. Decreasing R st to 0.57 reduced this value to 634 mg/m 3 (6 % O 2 ) with carbon levels in the fly ash and slag of 5.17 % and 3.67 %, respectively. Air-staging combustion is evidently a reasonable approach to controlling NO x emissions when burning HAC. While for UHAC, it was necessary to appropriately reduce the air-staging degree to enhance combustion and maintain low NO x emissions.

Characteristics of NO release for the combustion of chars and volatiles of Anthracite

The Characteristic of NO Release for the Chars and Volatiles of Bituminous During Combustion

Experimental and modeling investigation on char combustion and char-nitrogen evolution characteristics under different conditions

Conversions of fuel-N, volatile-N, and char-N to NO and N2O during combustion of a single coal particle in O2/N2 and O2/H2O at low temperature

An Experimental Research on the NO Release Characteristics of Low Volatile Coal

Experimental investigations of the conversion of fuel-N, volatile-N and char-N to NOx and N 2 O during single coal particle fluidized bed combustion

Anthracite-Char Activities to NO Reduction

Experimental Research on the Combustion and NO_x Generation Characteristics of Low Volatile Coal

Combustion Kinetics Characteristics and Experimental Study on NOx Formation Mechanism of Guizhou Anthracite

Release of NOx Precursors During Coal Combustion

Studies on NO x formation and reduction characteristics in high-ash, low-volatile coal combustion by mechanism experiments and industrial-scale trials

A comprehensive study of char reaction kinetics: Does CO always promote NO reduction on char surface?

Studies of the Release Rule of NOx Precursors During Gasification of Coal and Its Char

NO Emission During Combustion of Anthracite and Bituminous Coal in O2/CO2 Atmosphere

Investigation on the volatile combustion and Fuel-N to NO conversion during pulverized fuel ignition process

Experimental Study on NOx Formation and Reduction by Shenhua Coal During Combustion and Reburning

No Formation Characteristics in the Coal Combustion Process at Different Temperatures

Effect of calcium-based additives on NO release of coals under different combustion modes

Insights into the interaction between NO and char(N) containing different functional forms: Mechanistic, thermodynamic and kinetic studies

Combustion and NOx Emission Behavior of Chinese Coals

NO_x Emissions of Coal Combustion in O_2/CO_2