Abstract:In actual combustion facilities, coal chars are often generated using a variety of pyrolysis processes, such as secondary pyrolysis, which is characterized by a long residence time in high temperature zone. The effects of such processes on the conversion of char N to NO during combustion have seldom been explored. In this study, the releases of NO during the combustion of coal chars obtained from different pyrolysis processes in a drop tube and in a fixed bed reactor were investigated. In addition, the extent of char N/NO conversion was studied in relation to the char reactivity, pore surface structure and carbon conversion in a horizontal tube furnace. The results show that, compared with chars generated by a single pyrolysis, chars treated by a subsequent secondary pyrolysis process exhibit larger pore surface areas but less reactivity because of the thermal annealing resulting from a longer thermal history. Chars with higher intrinsic reactivity were also found to release a lower amount of NO. However, a weak correlation was identified between the apparent reactivity and char N/NO conversion, indicating that intrinsic reactivity is more important and directly determines the NO reduction process under combustion conditions. Moreover, char N/NO conversion was significantly affected by the coal rank, and a greater extent of conversion of char N to NO was observed in the case of high-rank coal chars. At a high combustion temperature (1373 K), variations in the bulk O-2 concentration had little effect on the char N/NO conversion, and an apparent correlation was found between the extents of char N/NO conversion and the accessible pore surface area. These results indicate that at high temperatures, the char N/NO conversion is directly determined by the accessible pore surface area due to transportation limitations. The NO/(CO + CO2) ratio increased with increasing burn-off in the latter stages of char conversion, which can be attributed to decreases in both the BET surface area and accessible pore surface area available for NO reduction during combustion.

Conversions of fuel-N, volatile-N, and char-N to NO and N2O during combustion of a single coal particle in O2/N2 and O2/H2O at low temperature

Conversions of fuel-N to NO and N 2 O during devolatilization and char combustion stages of a single coal particle under oxy-fuel fluidized bed conditions

Experimental investigations of the conversion of fuel-N, volatile-N and char-N to NOx and N 2 O during single coal particle fluidized bed combustion

No and N2o Emissions During Devolatilization and Char Combustion of A Single Biomass Particle under Oxy-Fuel Conditions at Fluidized Bed Temperature

Experimental Study Of Volatile-N Conversion At O-2/Co2 Atmosphere In A Drop Tube Furnace

Experimental study of the NO and N2O emissions during devolatilization and char combustion of a single biomass particle in O2/N2 and O2/H2O under low temperature condition

Experimental Study of Influence of Temperature on Fuel-N Conversion and Recycle NO Reduction in Oxyfuel Combustion

Conversion of Volatile Nitrogen and Char Nitrogen to NO in Oxy-Biomass Combustion

Nitrogen/NO Conversion Characteristics of Coal Chars Prepared Using Different Pyrolysis Procedures under Combustion Conditions

Conversion of Fuel-N to N2O and NOx During Coal Combustion in Combustors of Different Scale

Experimental Study on Coal-Nitrogen Release and NO<i><sub>x</sub></i> Evolution in Oxygen-Enriched and Deep-Staging Combustion

Conversion of Char Nitrogen to NO in O;/CO; Environment

Experimental study of NO_x emissions from coal combustion under oxy-fuel conditions

Experimental and Numerical Evaluation of Coal-N Conversion Characteristic During Preheating-Combustion under O2/CO2 Atmosphere

Experimental and modeling investigation on char combustion and char-nitrogen evolution characteristics under different conditions

Experimental and numerical evaluation of coal-N conversion characteristic during preheating-combustion under O 2 /CO 2 atmosphere

Effects of Reaction Condition on the Emission Characteristics of Fuel-N During the O-2/H2O Combustion Process of Demineralized Coal

Effect of Reaction Conditions on Nitrogen Conversion During Char-O2/NO Combustion

Releases of NO and Its Precursors from Coal Combustion in a Fixed Bed

The characteristics and mechanism of the NO formation during oxy-steam combustion

Experimental Investigation of Ignition and Combustion Characteristics of Single Coal and Biomass Particles in O2/N2 and O2/H2O