Abstract:In actual combustion facilities, coal chars are often generated using a variety of pyrolysis processes, such as secondary pyrolysis, which is characterized by a long residence time in high temperature zone. The effects of such processes on the conversion of char N to NO during combustion have seldom been explored. In this study, the releases of NO during the combustion of coal chars obtained from different pyrolysis processes in a drop tube and in a fixed bed reactor were investigated. In addition, the extent of char N/NO conversion was studied in relation to the char reactivity, pore surface structure and carbon conversion in a horizontal tube furnace. The results show that, compared with chars generated by a single pyrolysis, chars treated by a subsequent secondary pyrolysis process exhibit larger pore surface areas but less reactivity because of the thermal annealing resulting from a longer thermal history. Chars with higher intrinsic reactivity were also found to release a lower amount of NO. However, a weak correlation was identified between the apparent reactivity and char N/NO conversion, indicating that intrinsic reactivity is more important and directly determines the NO reduction process under combustion conditions. Moreover, char N/NO conversion was significantly affected by the coal rank, and a greater extent of conversion of char N to NO was observed in the case of high-rank coal chars. At a high combustion temperature (1373 K), variations in the bulk O-2 concentration had little effect on the char N/NO conversion, and an apparent correlation was found between the extents of char N/NO conversion and the accessible pore surface area. These results indicate that at high temperatures, the char N/NO conversion is directly determined by the accessible pore surface area due to transportation limitations. The NO/(CO + CO2) ratio increased with increasing burn-off in the latter stages of char conversion, which can be attributed to decreases in both the BET surface area and accessible pore surface area available for NO reduction during combustion.

No Formation Characteristics in the Coal Combustion Process at Different Temperatures

An Experimental Research on the NO Release Characteristics of Low Volatile Coal

Experimental investigations of the conversion of fuel-N, volatile-N and char-N to NOx and N 2 O during single coal particle fluidized bed combustion

Experimental Research on the Combustion and NO_x Generation Characteristics of Low Volatile Coal

Releases of NO and Its Precursors from Coal Combustion in a Fixed Bed

Experimental and modeling investigation on char combustion and char-nitrogen evolution characteristics under different conditions

Conversions of fuel-N, volatile-N, and char-N to NO and N2O during combustion of a single coal particle in O2/N2 and O2/H2O at low temperature

NO Emission During the Co-Combustion of Biomass and Coal at High Temperature: an Experimental and Numerical Study

Study of the NO Formation Characteristics and Ammonia-N/coal-n Transformation Mechanism of Ammonia-Coal Co-Combustion in O2/CO2 Atmosphere

Release of NOx Precursors During Coal Combustion

Experimental Study on Coal-Nitrogen Release and NO<i><sub>x</sub></i> Evolution in Oxygen-Enriched and Deep-Staging Combustion

Experimental Study of Influence of Temperature on Fuel-N Conversion and Recycle NO Reduction in Oxyfuel Combustion

Nitrogen/NO Conversion Characteristics of Coal Chars Prepared Using Different Pyrolysis Procedures under Combustion Conditions

Effect of Oxygen Concentration on NO Formation during Coal Char Combustion

Characteristics of NO release for the combustion of chars and volatiles of Anthracite

Conversions of fuel-N to NO and N 2 O during devolatilization and char combustion stages of a single coal particle under oxy-fuel fluidized bed conditions

The Characteristic of NO Release for the Chars and Volatiles of Bituminous During Combustion

NO formation and destruction during combustion of high temperature preheated pulverized coal

No Emission Characteristics Of Low-Rank Pulverized Bituminous Coal In The Primary Combustion Zone Of A Drop-Tube Furnace

Experimental Investigation on the NO Formation of Pulverized Coal Combustion under High-Temperature and Low-Oxygen Environments Simulating MILD Oxy-Fuel Combustion Conditions

Experimental Study Of Volatile-N Conversion At O-2/Co2 Atmosphere In A Drop Tube Furnace