Abstract:The SO2/NOX pollution in the flue gas of non-ferrous smelting is increasingly serious. At the same time, the accumulation of red mud (RM) in the aluminum industry and phosphorus sludge (PS) in the yellow phosphorus industry has caused serious harm to the environment. To remove SO2 and NOX from the non-ferrous smelting flue gas and realize the resource utilization of the above two solid wastes, an ultrasonic field was used in this study to strengthen the PS excited O3 process and RM wet desulfurization and denitrification process. In the process of O3 excitation, the response surface method (RSM) is used to obtain the optimal O3 excitation concentration, and the optimal reaction conditions are designed based on the response surface optimization model: T is 53.226 °C, power density is 0.4 W/cm2, PS concentration is 51.433 g/L, O3 formation concentration up to 250 ppm or more, which provides a theoretical basis for subsequent desulfurization and denitrification steps. It is proved that this study can replace the expensive traditional O3 generator and provide a basis for NOX removal in the following process. In addition, the optimum experimental conditions of ultrasonic enhanced RM desulfurization and denitrification process were also explored. Under ultrasonic frequency of 28 kHz, ultrasonic power density of 0.4 W/cm2, T of 50 °C, RM concentration of 15 g/L, and stirring intensity of 1000 rpm, the desulfurization efficiency of the reaction system can be maintained above 95 % within 250 min, and the denitrification efficiency can be maintained above 90 % within 250 min. The effect of desulfurization and denitrification in this study is much better than that of traditional methods. Finally, the reaction mechanism of ultrasonic enhanced O3 excitation and RM wet desulfurization and nitrogen removal was discussed by combining adsorption thermodynamics, isotherm, and kinetics. The results showed that the OH· free radicals generated by ultrasonic cavitation and the physical effects brought by emulsification had significant promoting effects.

A NEW PROCESS OF SO2 REMOVAL FROM FLUE GAS WITH AQUEOUS SOLUTIONS OF HETEROPOLY ACIDS

Experimental study of new desulfurizer for removal of H2S

A Semi-Wet Technological Process for Flue Gas Desulfurization by Corona Discharges at an Industrial Scale

Reconfiguration of Acid Gas Removal Process Matching the Integration of Coal Chemical Industry with Green Hydrogen

Novel Method for High-Performance Simultaneous Removal of NOx and SO2 by Coupling Yellow Phosphorus Emulsion with Red Mud

A Superior Liquid Phase Catalyst for Enhanced Absorption of NO2 Together with SO2 after Low Temperature Ozone Oxidation for Flue Gas Treatment

Selective Sulfur Dioxide Absorption from Simulated Flue Gas Using Various Aqueous Alkali Solutions in a Polypropylene Hollow Fiber Membrane Contactor: Removal Efficiency and Use of Sulfur Dioxide

Mechanism of SO3/H2SO4 transformation and reduction in wet flue gas desulfurization systems

High Efficient Removal Of So2 And No Of Flue Gas In A Single Fluidized Bed Reactor

Experimental Study on Removal Characteristics of SO3 by Wet Flue Gas Desulfurization Absorber

Ultrasonic-enhanced Phosphorus Sludge Excited O3 Coupled Red Mud Simultaneous Desulfurization and Denitrification

Integrated Tests for Removal of Nitric Oxide with Iron Thiochelate in Wet Flue Gas Desulfurization Systems

Investigation on Removal Effects and Condensation Characteristics of Condensable Particulate Matter: Field Test and Experimental Study.

Improving the removal of SO 3 aerosol by combining flue gas condensation and alkali spray

Urine-marking by female mice throughout their reproductive cycle

An Adaptive Sorbent for the Combined Desulfurization/Denitration Process Using a Powder-Particle Fluidized Bed

Simultaneous Absorption of SO2 and NO from Flue Gas Using Ultrasound/fe2+/heat Coactivated Persulfate System

Simultaneous wet absorption of SO2 and NOX with mixed Na2SO3 and (NH4)2SO3: Effects of mass concentration ratio and pH

A Dry Process for Simultaneous Removal of SO2 and NO from Flue Gas of Power Plants by Using a Gas-Solid-Solid Fluidized Bed

Promoting the synergistic removal of SO 3 aerosols and particles during the flue gas condensation by combining alkali spray and turbulent agglomeration

Study on NOx Absorption Into(NH4)2SO3 Solution in the Process of Ammonia-based Wet Flue Gas Desulfurization