Abstract:Sulfur compounds are one of the most concerning pollutants in the petroleum industry. As a potential energy resource with high sulfur content, oily sludge has received increasing attention, yet little effort has been made to characterize the behavior of sulfur compounds during utilization. In this paper, sulfur compounds in the raw oily sludge collected from a crude oil tank were identified, and influences of temperature and potassium compounds (KC1 and KOH) on the transformation behavior of sulfur were investigated during the pyrolysis. Sulfur species retained in the solid residues were analyzed by X-ray photoelectron spectroscopy. Possible sulfur-participating reactions during pyrolysis were discussed. Results showed that inorganic sulfur was mainly presented in the form of sulfate in solid particles, and organic sulfur was presented in the oil phase. During pyrolysis, H2S was released due to the decomposition of aliphatic and aromatic sulfurs. The emission of H2S can be promoted by 100% from 350 to 450 degrees C, and this value was further increased by 16.7% under 450 degrees C in the presence of KCl. On the contrary, the addition of KOH can inhibit the release of H2S by 75%, and metal sulfide was observed in the solid residues, implying the conversion of organic sulfur to inorganic sulfur during pyrolysis. The sulfur remaining in the solid residues after pyrolysis was mainly in the forms of thiophenes and sulfate. With the addition of KOH, the relative content of thiophenes declined from 97.1% to 4.3% under 550 degrees C; at the same time, the sulfur retention in the solid residues was increased by 39.5%, while the sulfur content of the oil product was reduced by 16.2%. The mass balance of sulfur can reach up to 98% except in the case of KOH, indicating other sulfur-containing gases, such as COS, may be generated during pyrolysis. Upper results can be used for guiding the desulfurization of oily sludge during treatment.

The conditions affecting thermal stability of insoluble sulfur

Experimental study of new desulfurizer for removal of H2S

A novel and easy way to improve the thermal stability of insoluble sulfur by curing process

Molecular simulation studies on the properties of insoluble sulfur stabilizers

A Facile Way to Synthesis Insoluble Sulfur with High Thermal Stability by Low Temperature Melting Method

Molecular Simulation to Explore the Dissolution Behavior of Sulfur in Carbon Disulfide

Studies on the Low-Temp Oxidation of Coal Containing Organic Sulfur and the Corresponding Model Compounds

The Transformation Mechanism of H2S Beside the Water Wall under Reducing Condition

PREPARATION FOR PYRITE BY SOLVOTHERMAL METHOD

The Transformation Mechanism of H<sub>2</sub>S beside the Water Wall under Reducing Condition

Sulfur Transformation During Coal Pyrolysis with Char Heat Carrier

Thermodynamic and Mechanical Stability of Crystalline Phases of Li2S2

Research on Behavior of Sulfation Product at High Temperature

Solubility of elemental sulfur in pure organic solvents and organic solvent-ionic liquid mixtures from 293.15 to 353.15K

Effects of Temperature and Potassium Compounds on the Transformation Behavior of Sulfur during Pyrolysis of Oily Sludge

Mechanism Investigation On The Sulfation Of Condensed Sodium Chloride At 523-1023 K

Research on Some Related Mechanisms of Corrosive Sulfur Problems in Mineral Oils

Thermal Analysis Study on the Spontaneous Combustion of Oil Tank Contained Sulfur

The Study Of Decomposition Of Calcium Sulfate With Compound Molecule At High Temperature

Mechanism And Influencing Factors Of Spontaneous Combustion Of Oil Tank Containing Sulfur

Chemical stability and structure of organic sulfur in coal