Abstract:The moving bed biofilm reactor (MBBR) has certain advantages, such as high wastewater treatment efficiency, low maintenance and operating costs, and simple operation. It has emerged as a valuable option for small decentralized facilities. The filling ratio, aeration mode and aeration intensity are the main factors that affect the performance of MBBRs in wastewater treatment. However, the information that concerns the used criteria that pertain to the process design for the MBBR is not adequate. In this study, a three dimensional computational fluid dynamics (CFD) model was constructed and the maximum error was only 1.98%, which was much smaller than the traditional 2D-CFD model. The filling ratio, aeration mode and aeration intensity of MBBR were optimized by CFD model from the point of view of fluid mechanics. The results show that the fluidization performance of the filling is the best under the one-side aeration mode with 30% filling ratio. The cost-performance ratio of the reactor with 30% filling ratio was 1.53, 25% and 35% filling ratio were only 1.17 and 1.14 respectively. Increasing the aeration intensity could improve the fluidization performance. However, the effect of high aeration intensity on the fluidization performance of the carrier was limited and the energy consumption increased greatly. The results revealed that when the aeration intensity increased from 0.07 min-1 to 0.13 min-1, the proportion of the carrier area increased by 16.56%. The proportion of the carrier area with an aeration rate of 0.20 min-1 was only 4.23%, which is higher than 0.13 min-1. The main factors that control the fluidization of the carrier were the range of the flow zone and the flow velocity of the liquid. Increasing the range of the flow zone could facilitate the flow of the carriers. The critical value of the flow velocity of the liquid in the flow zone was 0.04 m/s. These results could guide the optimization design of the filling ratio and the aeration conditions and provide a theoretical basis for the application of MBBR.

Research on the biofilm formation during the start of external biological circulating fluidized bed

Enhanced Aquaculture Wastewater Treatment in a Biofilm Reactor Filled with Sponge/ferrous Oxalate/biochar Composite (Sponge-C2feo4@nbc) Biocarriers: Performance and Mechanism

Enhancement of Mariculture Wastewater Treatment Using Moving Bed Biofilm Reactors Filled with Modified Biocarriers: Characterisation, Process Performance and Microbial Community Evaluation

Improvement of Inner Components in Biological Fluidized Bed Reactors for Wastewater Treatment

Study on Start-up and Operation of Anaerobic Attached Film Expanded Bed with Resin As Biofilm Carrier

Investigation on Start-Up and Operation of an Anaerobic Attached Microbial Film Expanded Bed with Ceramisites As Biofilm Carrier

Effects mechanism of bio-carrier filling rate on rotating biofilms and the reactor performance optimization method

Hydraulic flow pattern and performance of swirling flow anaerobic attached growth film expanded bed bioreactor

Numerical study of hydrodynamic characteristics in a moving bed biofilm reactor

[Experiment Study on Carriers in Moving Bed Biofilm Reactor].

Reviews on the Formation and Detachment of Biofilm in Anaerobic Fluidized Bed

Assessing the Effectiveness of Treating Coking Effluents Using Anaerobic and Aerobic Biofilms

Characterizing and comparing microbial community and biofilm structure in three nitrifying moving bed biofilm reactors

Hydrodynamic Characteristics of Airlift Nitrifying Reactor Using Carrier-Induced Granular Sludge

Influence of Carrier Concentration on the Performance and Microbial Characteristics of a Suspended Carrier Biofilm Reactor

Research on Low Concentration Wastewater Treated by Inner Cycle of Aerobe in Three-phase Bio-fluidized Bed

Research progresses on suspended carrier in moving bed biofilm reactor for wastewater treatment

Research on the Treatment of Landfill Leathate by an External Biological Circulating Fluidized Bed

Performance of an Internal Circulating Three-Phase Fluidized Bed Bioreactor in Treating Petrochemical Wastewater

Conductive Carrier Promotes Synchronous Biofilm Formation and Granulation of Anammox Bacteria

CHARACTERISTICS OF SLUDGE IN ANAEROBIC ATTACHED FILM EXPANTION BED WITH RESIN AS BIOFILM CARRIER