Abstract:The evaporation of aviation kerosene droplets in the aeroengine combustion chamber is one of the basic processes during liquid fuel combustion, which directly affects fuel atomization, air-fuel mixture formation and the combustion quality. However, the data are rarely reported due to the difficulty of conducting experiments in high temperature and pressure conditions. In this study, a series of experiments were carried out to investigate the evaporation characteristics of RP-3 aviation kerosene droplet. The environmental pressure and temperature of droplet evaporation ranged from 1 and 20 bar and 400 and 600 °C respectively. An individual RP-3 kerosene droplet with initial diameter between 0.9 and 1.1 mm was suspended at a thermocouple bead with 50 μm diameter to measure droplet temperature. Droplet diameter during the whole evaporation process was recorded simultaneously by a high-speed camera. Experimental results indicated that at lower evaporation rate, RP-3 kerosene droplet evaporation experienced two processes: transient heating and equilibrium evaporation periods. While under high evaporation rates, the droplet only underwent equilibrium evaporation period without droplet expansion. At all the studied temperatures, droplet temperature kept increasing during the entire evaporation process without reaching a stable temperature. In most cases, the transient evaporation rate ( K ) of RP-3 kerosene droplet first increased rapidly until reaching the peak, and then followed by a monotonous decrease. However, at 20 bar above 500 °C conditions, the temporal K curve exhibited a double-peak feature. Above the critical temperature of the fuel, increasing ambient pressure and temperature both can promote the heating and evaporation. However, the promotion of increasing ambient temperature to droplet evaporation was weakened at high ambient pressure. The quantitative correlations of droplet lifetime and evaporation rate constant with pressure were proposed under different ambient temperatures.

Experimental Study on Exponential Evaporation Rate Model of Several Liquid Fuels

The Influence of Evaporation and Ignition Model on the Methanol Spray Flame Simulation

Comparative Research on Laminar Flame Propagation for Four C8 Fuels

Experimental Study of Evaporation Characteristics of Acoustically Levitated Fuel Droplets at High Temperatures

Modeling of Supercritical-Pressure Turbulent Combustion of Hydrocarbon Fuels Using A Modified Flamelet-Progress-Variable Approach

Preferential Droplet Vaporization of a 24-Component Mixture under Different Ambient Temperature, Pressure and Force Convection

Effect of micro-explosion of biodiesel and ethanol droplets on evaporation: A three-stage mixed fuel droplet evaporation model

Measurement of Interacting Ethanol Droplets Evaporation at Moderately Elevated Temperature and Pressure Using Phase Rainbow Refractometry

Validation and analyses of RANS CFD models for turbulent heat transfer of hydrocarbon fuels at supercritical pressures

Numerical Simulation for Combustion of Droplet with Volume of Fluid Formulation

Modeling and Simulation of Supercritical-Pressure Turbulent Heat Transfer of Aviation Kerosene with Detailed Pyrolytic Chemical Reactions

Experimental research and estimation model of gasoline evaporative emissions from vehicles in China

A non-equilibrium evaporation model for a droplet and spray under diesel engine-relevant conditions

Evaporation Characterization Of Fuel Spray Impinging On A Flat Wall By Laser-Based Measurement

Evaporating Interface In A Capillary Tube With High Heat Flux Induced By Micro Diffusion Flame

Experimental investigation on evaporation characteristics of RP-3 aviation kerosene droplet above the critical temperature under various pressure conditions

Application of droplet motion and evaporation model in fuel spray in the constant volume bomb

Boiling Evaporation Of Typical Fuel Leaked On Heated Surface

A molecular dynamics study of evaporation of multicomponent stationary and moving fuel droplets in multicomponent ambient gases under supercritical conditions

Experimental Investigation on Evaporation Dynamics Behavior of Flammable Liquids

New method of experimental study on supercritical characteristic of single droplet fuel