Abstract:Post-combustion CO_2 absorption by amine has great potential for large-scale carbon capture and industrial promotion. However, in the process of efficiently absorbing CO_2, part of the absorbers will leave the carbon capture system in the form of aerosol along with the flue gas, which will not only lead to abnormal operation of the equipment but also cause environmental pollution. Therefore, the emission control of amine aerosol has become a new issue to be solved urgently in the industrial promotion of amine carbon capture. However, the amine carbon capture is still in the demonstration stage. Although attention has been paid to the emission control of amine aerosols at home and abroad, the formation and evolution of amine aerosols is a complex process affected by many factors such as absorption parameters and flue gas components. The actual emission of amine aerosols is quite different, which poses a challenge for the development of efficient and low-cost control technology and the establishment of emission limits. This paper introduces the significance of heterogeneous nuclei in heterogeneous nucleation of amine aerosols. The test methods of amine aerosol concentration and size are summarized. The emission of amine aerosols measured by different research institutions are compared. The size distribution characteristics of amine aerosols under different heterogeneous nuclei are determined. The effects of heterogeneous nuclei, CO_2 concentration, lean liquid temperature and solvent load on the formation and emission of amine aerosols are analyzed. Finally, the advantages and disadvantages of three types of amine emission control technologies, such as condensation pretreatment, in-tower regulation and efficient tail control, are summarized. In the future, the emission control of amine aerosols in amine carbon capture system should be integrated into the whole process of pollution reduction and carbon reduction, from reducing the formation of amine aerosols to promoting the aggregation and growth of amine aerosols, and finally realizes the collaborative control of multiple pollutants.

Aerosol Emissions of Amine-Based CO<sub>2</sub> Absorption System: Effects of Condensation Nuclei and Operating Conditions

Reducing Aerosol and Ammonia Emission in Post-Combustion CO2 Capture: Additives As Key Solutions

High amine emissions formation and aerosol particle size distribution in post-combustion CO2 capture process

Aerosol Emissions and Mitigation of Aqueous AMP/PZ Solvent for Postcombustion CO2 Capture

Research Status of Amine Aerosol Formation and Emission in Amine Carbon Capture Process

Insights into Aerosol Emission Control in the Postcombustion CO2 Capture Process: from Cluster Formation to Aerosol Growth.

Evaluation on water balance and amine emission in CO2 capture

Reducing aerosol and ammonia emission in post-combustion CO 2 capture: Additives as key solutions

Role of Absorber and Desorber Units and Operational Conditions for N-nitrosamine Formation During Amine-Based Carbon Capture

Research Progress on Amine Absorbent for CO2 Capture from Flue Gas

Solvent emissions control in large scale chemical absorption CO2 capture plant

CO2 Capture Using Amine Solution Mixed with Ionic Liquid

Insights into Aerosol Emission Control in the Postcombustion CO 2 Capture Process: From Cluster Formation to Aerosol Growth

Carbon dioxide capture by functionalized solid amine sorbents with simulated flue gas conditions.

Bench-scale CO2 Capture Using Water-Lean Solvent of 2-(Ethylamino) Ethanol, 1-Methyl-2-pyrrolidinone, and Water

Chemical absorption of carbon dioxide in non-aqueous systems using the amine 2-amino-2-methyl-1-propanol in dimethyl sulfoxide and N-methyl-2-pyrrolidone

Simulation of a CO_2 Capture System Using Amine Solutions for Selection of Absorbents

Mixed Amine Absorbent based on Hollow Fiber Membrane Contactor Removes CO2 from Flue Gas

CO 2 capture from flue gas using EAE-1DMA2P solvent in a packed column

Evaluation of CO2 Absorption and Stripping Process for Primary and Secondary Amines

Absorption and Regeneration Characteristics of Alkanolamines after CO2removal from Flue Gas