Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Impact of the Device Scaling on the Low-Frequency Noise in N-Mosfets

Low-frequency noise in narrow channel MOSFETs

Random Telegraph Signals And Low-Frequency Noise In N-Metal-Oxide-Semiconductor Field-Effect Transistors With Ultranarrow Channels

Influence of Channel Length, Thickness, and Crystal Orientation in Ultra-Scaled Double-Gate Pmosfets

Impact of Hot Carrier Degradation and Bias Temperature Instability on GHz Cycle-to-Cycle Variation in Ultra-Scaled FinFETs

Impact of Interface Traps Generation on Flicker Noise Degradation in SI Pmosfets

Characteristics of Random Telegraph Signals in NMOSFETs with Ultra Narrow Channels

Investigation of Low-Frequency Noise in Silicon Nanowire MOSFETs

Large Random Telegraph Noise In Sub-Threshold Operation Of Nano-Scale Nmosfets

Total-Ionizing-Dose Effects and Low-Frequency Noise in 30-Nm Gate-Length Bulk and SOI FinFETs with SiO2/HfO2Gate Dielectrics

Analysis of 3D Channel Current Noise in Small Nanoscale MOSFETs Using Monte Carlo Simulation

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Observation of Nonconservation Characteristics of Radio Frequency Noise Mechanism of 40-Nm N-Mosfet

Investigation on the Amplitude of Random Telegraph Noise (rtn) in Nanoscale Mosfets -Scaling Limit of "hole in the Inversion Layer" Model

Impact of Hot Carrier Aging on Random Telegraph Noise and Within A Device Fluctuation

Analysis of Channel Current Noise in Small Nanoscale Metal Oxide Semiconductor Field Effect Transistors

Temperature Dependent Variations of Low-Frequency Noise Sources in Cryogenic Short-Channel Bulk MOSFETs

Numerical modeling of RF noise in scaled MOS devices

Behavior of Low-Frequency Noise in N-Channel Metal–Oxide–Semiconductor Field-Effect Transistors for Different Impurity Concentrations

Time-Domain Modeling of Low-Frequency Noise in Deep-Submicrometer MOSFET

The Origins of Random Telegraph Noise in Highly Scaled SiON Nmosfets