Abstract:In this paper, the substitution of different amounts of Zr for Ti in the hydrogen storage electrode alloy Mg35Ti10Ni55 has been carried out for the purpose of further improving the electrochemical performance of the electrode alloy. The electrochemical properties were tested on the purposely prepared Mg35Ti10−xZrxNi55 (x=1, 3, 5, 7, 9) electrode alloys. The results showed that all alloys substituted with Zr possessed a higher cycling capacity retention and a larger initial discharge capacity (except Mg35Ti1Zr9Ni55) than the original alloy Mg35Ti10Ni55. Among these alloys Mg35Ti5Zr5Ni55 exhibited the highest discharge capacity and cycling stability. It was found from X-ray Photoelectron Spectroscopy (XPS) surface analysis that the Zr content reduced the degree of oxidation of Mg. The higher the Zr content, the lower is the degree of oxidation of Mg. Auger electron spectroscopy (AES) analysis revealed that the thickness of the passive oxide film coating on the alloy surfaces became first reduced as the Zr content increased but subsequently became augmented as the Zr content exceeded 5 at.%. The study indicated that the corrosion inhibiting effect of Zr alone, without the presence of Ti was weak. The synergetic effect of Zr and Ti made the passive film more compact, less pervious and more protective than by Ti or Zr alone. The thickness of the passive film agreed well with the polarization resistance of the alloys obtained from electrochemical impedance spectroscopy (EIS) Nyquist diagrams, suggesting that the surface polarization resistance RP being closely related to the film thickness and the exchange current density on the surface of the alloy varied accordingly. The conclusion of this study is that 5 at.% Zr substitution in Mg35Ti10Ni55 leads to the formation on the surface of a good and thin passive film, which retards the corrosion of the alloy and at the same time leads to the least polarization resistance and highest exchange current in this series of alloys studied.

Electronic Properties of Passive Films Formed on G3 and G30 Nickel-Based Alloys in Bicarbonate/Carbonate Buffer Solution

Chemical Composition and Mott-Schottky Analysis of Passive Film Formed on G3 Alloy in Bicarbonate/Carbonate Buffer Solution

Investigation on Electronic Property of Passive Film on Nickel in Bicarbonate/Carbonate Buffer Solution

Influence of Temperature, Chloride Ions and Chromium Element on the Electronic Property of Passive Film Formed on Carbon Steel in Bicarbonate/carbonate Buffer Solution

Investigation on the Composition and Semi-conductive Property of the Passive Film on 22Cr Duplex Stainless Steel

The effect of partial substitution of Zr for Ti on the electrochemical properties and surface passivation film of Mg35Ti10 - xZrxNi55 (x=1, 3, 5, 7, 9) electrode alloys

The semi-conductor property and corrosion resistance of passive film on electroplated Ni and Cu-Ni alloys

The effect of partial substitution of Ti with Zr, Cr or V in the Mg35Ti10Ni55 electrode alloy on its electrochemical performance

Systematic Insight into Chloride Concentration, Applied Potential and Time Effect on the Passive Film of Cu-Zn-Ni Ternary Alloy in Alkaline Solution

The electronic structure of passive films formed on stainless steels

The Formation Of Passive Films Of Carbon Steel In Borate Buffer And Their Degradation Behavior In Nacl Solution By Secm

Semiconducting properties of oxide and passive films formed on AISI 304 stainless steel and Alloy 600

Stability of passive film and antibacterial durability of Cu-bearing L605 alloy in simulated physiological solutions

Investigation of passive films formed on the surface of alloy 690 in borate buffer solution

Corrosion Susceptibility of Passive Films on 1060, 2024, and 5083 Aluminum Alloys: Experimental Study and First-Principles Calculations

Structure and Composition of the Passive Film Studied Using a Combination of X-Ray Photoelectron Spectroscopy, Secondary Ion Mass Spectrometry, and Scanning Transmission Electron Microscopy

Corrosion Resistance, Composition, and Stratification of Passive Films: Ni-22Cr and Ni-22Cr-6Mo Alloys Passivated and Exposure Aged in Acidic Chloride Solutions

Corrosion and passive behavior of AlxCrFeNi3−x (x = 0.6, 0.8, 1.0) eutectic high entropy alloys in chloride environment

A Pre-Passive State Observed for the Passive Film Formed on Alloy 625 in a Hydrochloric Acid Solution

Passivation of Ni-Cr and Ni-Cr-Mo Alloys in Low and High pH Sulfate Solutions

Surface corrosion enhancement of passive films on NiTi shape memory alloy in different solutions