Abstract:A combined computational/experimental study is performed to investigate hypersonic low-density internal gas flows in a convergent-divergent nozzle over a wide range of Knudsen numbers. The numerical solutions are obtained using the direct simulation Monte Carlo (DSMC) method and the experimental measurement is conducted in the hypersonic low-density wind tunnel FengDong-19 (FD-19) at China Academy of Aerospace Aerodynamics. Rarefaction effects are found to play an important role in pressure disturbance propagation, flow separation (vortex formation), mass flow rate, velocity slip, and thermally nonequilibrium effect. Pressure disturbance propagates farther upstream with increasing free-stream Knudsen number Kn∞. Although there is no flow separation near the nozzle surface for Kn∞ = 0.1, the slip velocity is such anomalously small that it cannot suppress flow separation, thus, producing one small vortex for Kn∞ = 0.2, 0.5 and 1. Due to the presence of the continuous sheet of two-order Moffatt vortices, the skin friction coefficient does not change sign (positive to negative) in the small separated region. This indicates that the incipient and small separated flows with second-order vortices may not be discerned by examining the sign of the skin friction. As Kn∞ grows to 2, this small vortex disappears. However, with further increase in Kn∞, a large vortex nearly fills the compression section of the nozzle due to the backflow effect. As Kn∞ increases from continuum to free molecular regime, the dimensionless mass flow rate mfr/mfr∞ rises first to its maximum at Kn∞ ∼ 0.2 resulting from the weaker flow blockage effect. After the maximum point, mfr/mfr∞ dwindles first because of the stronger backflow effect and rises again to its free molecular limit, obtaining its minimum (the so-called Knudsen minimum) at Kn∞ ∼ 10. DSMC results and experimental data obtained from FD-19 wind tunnel are in good agreement, achieving a mutual validation between computation and experiment. This indicates that our experiment provides valuable data that can server as “benchmark” case to support computational code evaluation and validation.

Numerical Study of Heat Flux Reduction Mechanism of the Counterflowing Jet in Rarefied Flows

Computational Study of Lateral Jet Interaction in Hypersonic Thermochemical Non-Equilibrium Flows Using Nonlinear Coupled Constitutive Relations

Numerical Simulation of Hypersonic Thermochemical Nonequilibrium Flows Using Nonlinear Coupled Constitutive Relations

Computational Simulation of Reentry Flows over Hypersonic Vehicles Using Nonlinear Coupled Constitutive Relations

Computation of Hypersonic Transitional Flows Over Cones Using Gas-Kinetic Scheme Coupled with the Turbulence Model

Flow and Heat Transfer Characteristics in a Microchannel with a Circular Synthetic Jet

An Improved Hybrid Particle Scheme for Hypersonic Rarefied-Continuum Flow

Numerical study on drag and heat flux reduction induced by a counterflowing jet for rarefied hypersonic flow over a blunt body

Aero Heating Optimization of a Hypersonic Thermochemical Non-Equilibrium Flow around Blunt Body by Application of Opposing Jet and Blunt Spike

Computational Study of Drag Reduction at Various Freestream Flows Using A Counterflow Jet from A Hemispherical Cylinder

Modeling and Analysis of Fluid-Solid Coupling Heat Transfer and Fluid Flow in Transonic Nozzle

Assessment on jet direction effect on drag and heat reduction efficiency for hypersonic vehicles

DSMC Numerical Simulation for Flow around 2-D Blunt Bodies with Unstructured Grid

Flow and heat transfer analysis of laminar flow in hypersonic aircraft with variable specific heat capacity at small attack angles

Investigation of shock-shock interaction in hypersonic rarefied flow using direct simulation Monte Carlo method

Coupled fluid–thermal analysis of the reduction mechanism for the drag and heat flux induced by jet interaction in a hypersonic reusable launch vehicle

Numerical investigation of blunt body's resistance and heat reduction with combination of airway spike and root jet

Numerical and Experimental Investigation of Rarefied Hypersonic Flow in a Nozzle

Numerical study of a composite cooling method for hypersonic aircraft

Heat and drag reduction of single and combined opposing jets in hypersonic nonequilibrium flows

Numerical study on heat and drag reduction by transpiration in hypersonic flow