Abstract:A combined computational/experimental study is performed to investigate hypersonic low-density internal gas flows in a convergent-divergent nozzle over a wide range of Knudsen numbers. The numerical solutions are obtained using the direct simulation Monte Carlo (DSMC) method and the experimental measurement is conducted in the hypersonic low-density wind tunnel FengDong-19 (FD-19) at China Academy of Aerospace Aerodynamics. Rarefaction effects are found to play an important role in pressure disturbance propagation, flow separation (vortex formation), mass flow rate, velocity slip, and thermally nonequilibrium effect. Pressure disturbance propagates farther upstream with increasing free-stream Knudsen number Kn∞. Although there is no flow separation near the nozzle surface for Kn∞ = 0.1, the slip velocity is such anomalously small that it cannot suppress flow separation, thus, producing one small vortex for Kn∞ = 0.2, 0.5 and 1. Due to the presence of the continuous sheet of two-order Moffatt vortices, the skin friction coefficient does not change sign (positive to negative) in the small separated region. This indicates that the incipient and small separated flows with second-order vortices may not be discerned by examining the sign of the skin friction. As Kn∞ grows to 2, this small vortex disappears. However, with further increase in Kn∞, a large vortex nearly fills the compression section of the nozzle due to the backflow effect. As Kn∞ increases from continuum to free molecular regime, the dimensionless mass flow rate mfr/mfr∞ rises first to its maximum at Kn∞ ∼ 0.2 resulting from the weaker flow blockage effect. After the maximum point, mfr/mfr∞ dwindles first because of the stronger backflow effect and rises again to its free molecular limit, obtaining its minimum (the so-called Knudsen minimum) at Kn∞ ∼ 10. DSMC results and experimental data obtained from FD-19 wind tunnel are in good agreement, achieving a mutual validation between computation and experiment. This indicates that our experiment provides valuable data that can server as “benchmark” case to support computational code evaluation and validation.

DSMC Numerical Simulation for Flow around 2-D Blunt Bodies with Unstructured Grid

Numerical Study of Heat Flux Reduction Mechanism of the Counterflowing Jet in Rarefied Flows

Modeling and numerical simulation of gas-solid jet in the transitional-rarefied regime

Numerical Simulation of Hypersonic Thermochemical Nonequilibrium Flows Using Nonlinear Coupled Constitutive Relations

Analysis of Electromagnetic Scattering Characteristics for a HTV-2 Type Flight Vehicle Ablation Flows

Computational Study of Lateral Jet Interaction in Hypersonic Thermochemical Non-Equilibrium Flows Using Nonlinear Coupled Constitutive Relations

Computational Simulation of Reentry Flows over Hypersonic Vehicles Using Nonlinear Coupled Constitutive Relations

Numerical study of aerodynamic heating and shock detached distance for sharp leading edge

Computation of Hypersonic Transitional Flows Over Cones Using Gas-Kinetic Scheme Coupled with the Turbulence Model

Investigation of shock-shock interaction in hypersonic rarefied flow using direct simulation Monte Carlo method

DSMC Algorithm and Heat Transfer Analysis of High Temperature and High Velocity Rarefied Gas Flow

Numerical Computation and Flowfield Analysis of Hypersonic Flow over a Double-Cone Body

Simulation of Flow and Heat Transfer in Micro Couette Flow

Numerical simulation of three dimensional supersonic and hypersonic unsteady flow fields

Numerical Simulation for Rarefied Hypersonic Flows over Non-Rectangular Deep Cavities

Anisotropic unstructured mesh adaption for supersonic flow simulation

DSMC Simulation and Experimental Validation of Shock Interaction in Hypersonic Low Density Flow

Numerical study on drag and heat flux reduction induced by a counterflowing jet for rarefied hypersonic flow over a blunt body

Three-dimensional DSMC Calculation and Heat Transfer Analysis of Four Capsules for Hypersonic Rarefied Conditions

Numerical and Experimental Investigation of Rarefied Hypersonic Flow in a Nozzle

Numerical Simulations of Morphology, Flow Structures and Forces for a Sonic Jet Exhausting in Supersonic Crossflow