Abstract:Cylindrical cm-sized dolomite particles were decomposed using the two steps decomposition scheme. Several studies on dolomite decomposition have been done using μm- to mm-sized samples over the years. However, these sizes are too small for industrial kiln application and ignore the influence of important parameters, e.g. thermal conductivity, on the decomposition process. In this work, the decomposition behavior of lumpy dolomite particles in each step was investigated. Experimentally measured sample temperature and conversion profiles in steps 1 and 2 are respectively similar to those obtained for the decomposition of pure magnesite and limestone. To measure the core temperature and conversion is to essentially analyze the decomposition behavior. The thermophysical material properties of the decomposition product in each step as a function of temperature was estimated using the shrinking core model. Finite difference method was employed in solving the 1D heat equation describing the process. The reaction rate coefficient in step 1 is shown to have a weak temperature dependence, the thermal conductivity of the product, MgO∙CaCO 3 , slightly increases with temperature but the permeability is not dependent. In step 2, the reaction coefficient and MgO∙CaO thermal conductivity and pore diffusivity do not show a clear temperature dependence. Finally, the sensitivity of the material and transport properties on the decomposition process was studied under shaft kiln condition. Thermal conductivity is observed to have the highest influence on decomposition with a value of up to 60 % at 1400 °C and for 120 mm particles.

Numerical Research on Thermal Decomposition Reaction Kinetics of Large Particle Size Limestone

Advances in calcium carbonate thermal decomposition

Model and Parameter Study of Limestone Decomposition Reaction

Decomposition Kinetics Of Nano-Particle Calcite

Study on the non-isothermal decomposition kinetics of AlOOH coated calcium carbonate

Experimental Study on the Impaction of Particle Size to Limestone Decomposition Kinetics by Thermogravimetry

The decomposition kinetics of the SiO2 coated nano-scale calcium carbonate

The Non-isothermal Kinetic Analysis of Thermal Decomposition of Mg(OH)2

The Kinetic Mechanism of the Thermal Decomposition Reaction of Small Particles of Limestone at Steelmaking Temperatures

Thermogravimetric Experiment Research on Thermal Decomposition Mechanics of Calcium Carbonate

Decomposition Mechanism and Calcination Properties of Small-Sized Limestone at Steelmaking Temperature

Study on the Character of Calcium Sulfate Reducing Decomposition

Decomposition mechanism of lumpy dolomite particles

Application of Non‐Arrhenius Equations in Interpreting Calcium Carbonate Decomposition Kinetics: Revisited

Experimental Study on Calcination and Fragmentation Characteristics of Limestone in Fluidized Bed

Simulation of Thermal Decomposition of Calcium Oxide in Water with Different Activation Energy and the High Reynolds Number

Numerical Simulation and Experimental Research on Calcination of Ultra-Fine Limestone

Decomposition kinetics study of AlOOH coated calcium carbonate

Parameters effect and optimization on calciner for treating magnesium salt based on computational fluid dynamics

Effect of Particle Size in a Limestone-Hydrochloric Acid Reaction System.