Abstract:Weakly-agglomerated nanocrystalline (ZrO2)(1-x)(Sc2O3)(x) ( x = 0.02 - 0.16) powders with high surface area (106 - 186 m(2) g(-1)) and uniform particle size (5.7 - 9.5 nm) were synthesized by a two-step hydrothermal process in the presence of urea, and their complex phase evolution upon calcinations over 400 - 1400 degreesC were studied by a combined utilization of X-ray diffraction, in situ high temperature X-ray diffraction, near infrared Fourier transform Raman and ultraviolet Raman spectroscopies. It was discovered that the growth of the grains comprised two stages, and the apparent activation energies, E-a1 (<800 degrees C) and E-a2 (>800 degreesC), are in the range of 5.5 - 12 kJ mol(-1) and 80 - 140 kJ mol(-1), respectively. The crystallite size, microstrain, surface area and growth activation energy of the samples showed a strong dependence on the Sc3+ doping concentration. The nanocrystalline (ZrO2)(1-x)(Sc2O3)(x) samples underwent complex phase transitions upon calcination from 800 to 1000 degreesC. Tetragonal and cubic phases have been preserved when the samples calcined below 800 degreesC as a result of crystallite size and doping effects. At elevated calcination temperature of 1000 degreesC, the compositions at x = 0.04, 0.10 and 0.14 seemed to be in the metastable phase boundaries of m + t, t + beta (Sc2Zr7O17) and beta+gamma (Sc2Zr5O13), respectively. As calcined at 1400 degreesC, the grain size was in the micrometre regime, and t --> m, c --> t", c --> beta and c --> gamma phase transitions occurred on the cooling stage for x less than or equal to 0.04, x = 0.08, 0.10 less than or equal to x less than or equal to 0.12 and x greater than or equal to 0.14, respectively, resulting in the existence of m, t, t", beta and gamma phases in turn at room temperature. Moreover, it was found that the tetragonal phase has been enriched at the surface region for the as-calcined (ZrO2)(0.94)(Sc2O3)(0.06) and (ZrO2)(0.92)(Sc2O3)(0.08) samples.

Isothermal Tetragonal-To-Monoclinic Phase Transformation In Y2o3-Partially Stabilized Zirconia: The Influence Of Grain Size

Phase Transformation in Y2O3‐Partially‐Stabilized ZrO2 Polycrystals of Various Grain Sizes During Low‐Temperature Aging in Water

Microstructural dependence of aging induced phase transformation in Y2O3 partially stabilized ZrO2 polycrystals

Formation and Rate Processes of Y2o3 Stabilized Zro2 Thin Films from Zr(Dpm)(4) and Y(Dpm)(3) by Cold-Wall Aerosol-Assisted Mocvd

Fabrication of Submicron Tetragonal Polycrystalline ZrO2 by the Transformation of Micro Monoclinic ZrO2 under High Pressure

[Study on Low Temperature Degradation of Dental Zirconia Ceramic].

Size-driven phase transformation and microstructure evolution of ZrO2 nanocrystallites associated with thermal treatments

Atomic force microscopy study of the tetragonal to monoclinic transformation behaviour of silica doped yttria-stabilized zirconia

Influence of Y2O3 Doping on Phase Evolution and Dielectric Characteristics of ZrO2 Ceramics

Tetragonal‐to‐Monoclinic Phase Transitions in Nanocrystalline Rare‐Earth‐Stabilized Zirconia Prepared by a Mild Hydrothermal Method

Effect of Y2O3 Contents and Grain Sizes on the Mechanical Properties and Transformation of Zirconia Ceramics at Cryogenic Temperatures

An EXAFS Study of the Nanocrystalline Transformation of ZrO2:Y2O3(5%)

Critical effect of cubic phase on aging in 3 mol% yttria-stabilized zirconia ceramics for hip replacement prosthesis

Influence of a small amount of Al2O3 addition on the transformation of Y2O3-partially stabilized ZrO2 during annealing

Mobility Transition at Grain Boundaries in Two-Step Sintered 8 mol% Yttria Stabilized Zirconia

Mobility Transition at Grain Boundaries in Two-Step Sintered 8mol% Yttria-Stabilized Zirconia

A quantitative microscopic view on the gas‐phase‐dependent phase transformation from tetragonal to monoclinic ZrO2

Effect of thermal treatment at high temperature on phase stability and transformation of Yb2O3 and Y2O3 co-doped ZrO2 ceramics

X‐ray Photoelectron Spectroscopy Investigation on the Low‐Temperature Degradation of 2 Mol% Y2O3‐ZrO2 Ceramics

A further step toward the understanding of phase transformation mechanism between 10 wt. % dysprosia stabilized zirconia powders and ceramics

Doping and Grain Size Effects in Nanocrystalline ZrO2–Sc2O3system with Complex Phase Transitions: XRD and Raman Studies