Abstract:In this investigation, a novel heat-sensitive material titanium oxide (TiOx) thin film was deposited on well cleaned K9 glass substrates by d.c. reactive magnetron sputtering from a metallic titanium target in an Ar + O2 gas mixture. In order to obtain proper TiOx thin films, deposition parameters should be properly controlled. In our system, TiOx thin films were obtained at different substrate temperature while total pressure and oxygen partial pressure were kept at 1 Pa and 0.6 Pa, d.c. power of 100 W, and the deposition time was adjusted in order to deposit thin films with a constant thickness close to 200 nm. The crystalline structure was characterized by X-ray diffraction (XRD) analysis and the results show that all the deposited films have an amorphous structure. In this paper, we have mainly investigated the dependence of electrical and optical properties of the reactively sputtered TiOx thin films on the different substrate temperature during the sputtering process, i.e., as the K9 glass substrate temperature increases from 100 °C to 250°C, the sheet resistance Rs of TiOx thin films is ranged from 305 kΩ/square to 36 kΩ/square, temperature coefficient of resistance (TCR) value up to -2.12 %/K is obtained, optical band gap decreases from 3.34 eV to 3.28 eV. Through the analysis and discussion of the above experimental data, we could obtain the conclusion that the variation in substrate temperature during the sputtering deposition plays a considerable important role in the electrical and optical properties of all the deposited films.

Influence of Substrate on Structural Properties and Photocatalytic Activity of TiO2 Films

Influence of Iron Dopant on Crystallization and Photo-Induced Hydrophilicity of TiO2 Thin Films

Controllable Hydrothermal Synthesis, Optical and Photocatalytic Properties of TiO2 Nanostructures

Influence of Substrate on Structural, Morphological and Optical Properties of TiO2 Thin Films Deposited by Reaction Magnetron Sputtering

Study of Self-Cleaning and Low-Emission Properties of FTO/TiO2 Composite films

Impact of Thickness of Columnar Crystal TiO2 Film on Photocatalytic Activity of FTO/TiO2 Coated Glass

Study on Structural, Optical and Hydrophilic Properties of FTO/TiO2 Tandem Thin Film Prepared by Aerosol-Assisted Chemical Vapor Deposition Method

Characterization and Photocatalytic Activity of Tio2 Films Loaded on Different Substrates

The Effects of Substrate on the Properties of Sol-Gel Derived TiO2 Films

Photocatalytic Activity and Low-Emissivity Property of Fluorine Doped SnO2/TiO2 Composite Film

Effect of Substrate Temperature on Structural Properties and Photocatalytic Activity of TiO2 Thin Films

Influence of Substrate Temperature on Surface Morphology and Properties of Titanium Oxide Thin Films

Investigation of microstructure evolution in Pt-doped TiO2 thin films deposited by rf magnetron sputtering

TiO2 films prepared by DC reactive magnetron sputtering at room temperature: Phase control and photocatalytic properties

Effects of Electron Transfer between TiO<sub>2</sub>Films and Conducting Substrates on the Photocatalytic Oxidation of Organic Pollutants

Effect of Substrate Type on the Electrical and Structural Properties of TiO2 Thin Films Deposited by Reactive DC Sputtering

Influence of Interface Diffusion Between Al Substrate and Tio2 Film on Photocatalytic Activity

The Influence of Substrate Temperature on the Electrical and Optical Properties of Titanium Oxide Thin Films Prepared by D.c. Reactive Magnetron Sputtering

Deactivation Of Tio2 Films On Titanium, Aluminums And Glass Substrates

Effects of substrate on the properties of sol-gel derived TiO2 films

Effects of substrate temperature on the microstructure and photocatalytic reactivity of TiO2 films