Abstract:This work investigates the effects of two kinds of iron ore on the pyrolysis characteristics of a low-rank bituminous coal from Hami, China. The pyrolysis and its product distribution were studied using a thermogravimetric analyzer and a fixed bed reactor. A gas chromatograph and a gas chromatograph mass spectrometer were employed to test the properties and composition of the pyrolytic products. Results showed that the pyrolysis temperature of the raw coal ranged mainly from 350 to 650 degrees C. The weight-loss rate reached a maximum of 6.95%/min at 443 degrees C. The weight loss was 44.27% at the final pyrolysis temperature of 750 degrees C. The tar yield of raw coal was 9.51% in the fixed bed reactor at 600 degrees C. Adding iron ore, which was intended for a lower tar yield and a higher fraction of light tar (boiling point <360 degrees C), had a catalytic effect on the pyrolysis of raw coal. With separate addition of hematite and specularite, both having a mass of 20% of the raw coal, coal weight loss increased by 3.86% and 5.56%, respectively, when the catalytic upgrading was at 600 degrees C, and good upgrading effect was obtained. Meanwhile, benzene homologue in tar increased slightly, by 0.62% and 1.44%, compared to that in the tar of the raw coal. The upgrading effects of iron ore on tar also lowered element O content in the resulting tar, by 36.89% with the addition of hematite and by 43.16% with specularite. The iron concentrate recovered was measured by magnetic separation method. The iron concentrate grade was 52.97% with hematite added in coal when the residence time of ultimate pyrolysis temperature was 25 min and the magnetic field strength was 96.48 kA/m, while it was 58.02% with specularite added when the residence time was 35 min and the magnetic field strength was 109.27 kA/m, both with a char grinding fineness of less than 0.074 mm (ground char accounting for approximately 80% of total char); iron concentrate recovery rate was 85.31% and 76.74%, respectively. The experimental results proved the feasibility of recovering iron ore in char by magnetic separation.

Gasification of pine sawdust via synergetic conversion using iron ore as a catalyst

In-depth study on the synergistic conversion mechanism of iron ore with waste biochar for co-producing directly reduced iron (DRI) and syngas

The Reaction Characteristics and Mechanism of Pine Sawdust Chemical-Looping Gasification Based on CoFe 2O 4 Oxygen Carrier

Synergistic conversion of iron ore sintering dust and waste biochar to produce direct reduction iron and syngas: Gasification, reduction behavior and thermodynamic analysis

An iron ore-based catalyst for producing hydrogen and metallurgical carbon via catalytic methane pyrolysis for decarbonisation of the steel industry

Co-pyrolysis of dyeing sludge and pine sawdust in a fluidized bed: Characterization and analysis of pyrolytic products and investigation of synergetic effects

Study of Smelting Reduction Iron Coupled with Pulverized Coal Gasification to Produce High-Concentration Syngas

Fast pyrolysis of biomass waste for hydrogen-rich gas

Direct Reduction Ironmaking by Co-Pyrolysis of Biomass Tar Model Compounds and Iron Ore Fines

Activated char supported Fe-Ni catalyst for syngas production from catalytic gasification of pine wood

Iron powder in-situ catalytic pyrolysis on coated wooden board: Kinetic, products, and recovery

Application of a Clean Fuel Produced by Electrolysis in Iron Ore Sintering Process: Brown Gas Injection to Assist Sintering

Hydrogen-Rich Gas Production from Two-Stage Catalytic Pyrolysis of Pine Sawdust with Calcined Dolomite

Catalytic Steam Gasification of Mengdong Coal in the Presence of Iron Ore for Hydrogen-Rich Gas Production

THE STUDY OF PINE SAWDUST STEAM CATALYTIC GASIFICATION TO PRODUCE HYDROGEN AND LARGE PARTICLE GASIFICATION KINETIC MODEL

Aromatic chemicals by iron-catalyzed hydrotreatment of lignin pyrolysis vapor

Hydrogen-Rich Gas Production from Two-Stage Catalytic Pyrolysis of Pine Sawdust with Nano-NiO/Al2O3 Catalyst

Process Simulation of Staging Pyrolysis and Steam Gasification for Pine Sawdust

Effects of Iron Ores on the Pyrolysis Characteristics of a Low-Rank Bituminous Coal

The Removal of Tar and the Production of Methane-Rich Gas from Biomass Hydrogen Pyrolysis by Using Biochar-Based Catalysts

Gasification Behavior of Phosphorus during Hydrogen-rich Sintering of High-phosphorus Iron Ore