Abstract:Post deposition annealing of molecular layer-deposited (MLD) hafnicone films was examined and compared to that of hafnium oxide atomic layer-deposited (ALD) films. Hafnicone films were deposited using tetrakis(dimethylamido)hafnium (TDMAH), and ethylene glycol and hafnia films were deposited using TDMAH and water at 120 °C. The changes in the properties of the as-deposited hafnicone films with annealing were probed by various techniques and then compared to the as-deposited and annealed ALD hafnia films. In situ X-ray reflectivity indicated a 70% decrease in thickness and ∼100% increase in density upon heating to 400 °C yet the density remained lower than that of hafnia control samples. The largest decreases in thickness of the hafnicone films were observed from 150 to 350 °C. In situ X-ray diffraction indicated an increase in the temperature required for crystallization in the hafnicone films (600 °C) relative to the hafnia films (350 °C). The changes in chemistry of the hafnicone films annealed with and without UV exposure were probed using Fourier transformed infrared spectroscopy and X-ray photoelectron spectroscopy with no significant differences attributed to the UV exposure. The hafnicone films exhibited lower dielectric constants than hafnia control samples over the entire temperature range examined. The CF4/O2 etch rate of the hafnicone films was comparable to the etch rate of hafnia films after annealing at 350 °C. The thermal conductivity of the hafnicone films initially decreased with thermal processing (up to 250 °C) and then increased (350 °C), likely due to porosity generation and subsequent densification, respectively. This work demonstrates that annealing MLD films is a promising strategy for generating thin films with a low density and relative permittivity.

Low energy Xe ion beam engineering in optical, structural and morphological properties of hafnium oxide thin films grown by atomic layer deposition technique

120 MeV Ag high energy irradiation effects in physical and chemical properties of ALD grown HfO2 thin films and their applications

Annealing Temperature Dependent Microstructure and Optical Properties of HfxTi1-xO2 Thin Films

Structural, optical and phonon properties of hafnium oxynitride thin films synthesized using plasma-enhanced atomic layer deposition

Modulation of the structural and optical properties of sputtering-derived HfO2 films by deposition power

Chemical, Structural, and Electrical Changes in Molecular Layer-Deposited Hafnicone Thin Films after Thermal Processing

Effect of Oxygen Flow on the Optical Properties of Hafnium Oxide Thin Films by Dual-Ion Beam Sputtering Deposition

Surface Morphology and Optical Properties of Hafnium Oxide Thin Films Produced by Magnetron Sputtering

Investigation of HfO2 Thin Films on Si by X-ray Photoelectron Spectroscopy, Rutherford Backscattering, Grazing Incidence X-ray Diffraction and Variable Angle Spectroscopic Ellipsometry

Growth Behavior Of Hafnium Oxide Film By Atomic Layer Deposition And Its Modulation

Microstructure, Optical Properties, and Optical Resonators of Hf1-Xtixo2 Amorphous Thin Films

Synthesis and Characterization of HfO2 and ZrO2 Thin Films Deposited by Plasma Assisted Reactive Pulsed Laser Deposition at Low Temperature

Physical Mechanism of Refractive Index Inhomogeneity of Hafnium Oxide Thin Film Prepared by Ion Beam Sputtering Technique

Growth Mode Evolution of Hafnium Oxide by Atomic Layer Deposition

Annealing behaviors of structural, interfacial and optical properties of HfO 2 thin films prepared by plasma assisted reactive pulsed laser deposition

Lanthanum doped hafnium oxide thin films deposited on a lateral high aspect ratio structure using atomic layer deposition: A comparative study of surface composition and uniformity using x-ray photoelectron spectroscopy and time-of-flight secondary ion mass spectrometry

Effect of low energy (keV) ion irradiation on structural, optical and morphological properties of SnO 2 –TiO 2 nanocomposite thin films

Studies on Optical and Electrical Properties of Hafnium Oxide Nanoparticles

Impact of post deposition annealing in O2 ambient on structural properties of nanocrystalline hafnium oxide thin film

Liquid Phase Deposition of Hafnium Oxide Thin Films

Thermal Stability, Structural and Electrical Characteristics of the Modulated Hfo2/Al2o3 Films Fabricated by Atomic Layer Deposition