Abstract:Chlorella sp., as a kind of microalgae with high proteins content and rigid cell walls, is a potential material for proteins recovery as poultry feed supplement source. This study proposed an algal biorefinery paradigm for sequent production of proteins and biogas from microalgae Chlorella sp. via CO2 assisted hydrothermal treatment and anaerobic digestion. The CO2 could be sustainably refilled as being a bioproduct of biogas. As a widely-used environmentally benign hydrothermal catalyst, the addition of CO2 could reduce treatment temperature and CO2 is easily removed by depressurizing. Microalgal cells were more disrupted with rising temperature from 70 degrees C to 150 degrees C, which facilitated the recovery of proteins. The recovery of proteins increased from 6.32% to 69.81%. After proteins recovery, the C/N ratio of microalgal residues was significantly higher than the untreated Chlorella sp. The process of proteins recovery could relieve the hydrolysis limitation of cell walls but reduce organics remained in microalgal residues. Biomethane production from microalgal residues exhibited a similar rising trend to proteins recovery. The highest cumulative biomethane production of 194.63 mL/gVS was achieved for the group at 130 degrees C, and the lowest value of 104.42 mL/gVS was obtained for the group at 70 degrees C. Excess microalgal cells disruption and side reactions led to the poor biomethane performance for the group at 150 degrees C, consistent with the decreased proteins recovery. During anaerobic digestion, the concentration of acetic acid distributed in a range of 0.05-0.44 g/L, which was dominant among total volatile fatty acids. The proteins as poultry feed supplement would be preferable to be considered as the main product, and the biomethane was considered as the side product. Carbon balance analysis revealed that most groups could basically meet the CO2 demand for HTT except the group at 150 degrees C. 130 degrees C was considered as the favorable treatment temperature level, leading to a proteins yield of 0.41 g/gVS and biomethane yield of 91.47 mL/gVS by Chlorella sp. (C) 2020 Elsevier Ltd. All rights reserved.

Sustainable Biohythane Production from Algal Bloom Biomass Through Two-Stage Fermentation: Impacts of the Physicochemical Characteristics and Fermentation Performance

Improving fermentative hydrogen and methane production from an algal bloom through hydrothermal/steam acid pretreatment

Inhibition of Thermochemical Treatment on Biological Hydrogen and Methane Co-Production from Algae-Derived Glucose/glycine

Coproduction of amino acids and biohythane from microalgae via cascaded hydrothermal and anaerobic process

Enhanced Biohydrogen and Biomethane Production from Chlorella Sp. with Hydrothermal Treatment

New Method for Algae Comprehensive Utilization: Algae-derived Biochar Enhances Algae Anaerobic Fermentation for Short-Chain Fatty Acids Production.

Cogeneration of Hydrogen and Methane from the Pretreated Biomass of Algae Bloom in Taihu Lake

How can hydrothermal treatment impact the performance of continuous two-stage fermentation for hydrogen and methane co-generation?

Bio-hydrogen production from anaerobic fermentation of sludge pretreated with α-amylase

Bacterial bioaugmentation for improving methane and hydrogen production from microalgae

Life-cycle assessment of biohythane production via two-stage anaerobic fermentation from microalgae and food waste

Hydrothermal hydrolysis of algal biomass for biofuels production: A review.

A Sequential Process of Anaerobic Solid-State Fermentation Followed by Dark Fermentation for Bio-Hydrogen Production from Chlorella Sp.

Bio-hythane Production from Residual Biomass of Chlorella Sp. Biomass Through a Two-Stage Anaerobic Digestion

Evaluation of Different Pretreatments on Organic Matter Solubilization and Hydrogen Fermentation of Mixed Microalgae Consortia

Hydrothermal Alkali Pretreatment Contributes to Fermentative Methane Production of a Typical Lipid from Food Waste Through Co-Production of Hydrogen with Methane.

Hydrothermal heating with sulphuric acid contributes to improved fermentative hydrogen and methane co-generation from Dianchi Lake algal bloom

Improvement of hydrogen production from Chlorella sp. biomass by acid-thermal pretreatment.

Sequent production of proteins and biogas from <i>Chlorella</i> sp. via CO<sub>2</sub> assisted hydrothermal treatment and anaerobic digestion

Biohydrogen Production by a Novel Integration of Dark Fermentation and Mixotrophic Microalgae Cultivation

Direct biohydrogen production from chitosan harvested microalgae biomass and an isolated yeast