Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

Solubilities of Difluoromethane (R32) in Polyol Ester, Polyvinylether, and Polyalkylene Glycol Base Oils at Temperatures from 273 K to 351 K

Solubilities of R32 in Polyol Ester and Polyvineyl Ether from 278.15 to 348.15 K

Vapor–Liquid Equilibria for the Binary Systems Difluoromethane (R32) + Trans-1,1,1,4,4,4-hexafluoro-2-butene (r1336mzz(e)) and Fluoroethane (R161) + Trans-1,1,1,4,4,4-hexafluoro-2-butene (R1336mzz(e))

Experimental Investigation for the Solubilities of 2,3,3,3-Tetrafluoroprop-1-ene (r1234yf) in Polyol Ester, Polyvinylether, and Polyalkylene Glycol Base Oils

Experimental Data and Description of the Phase Equilibrium in the Binary System of Ethyl Fluoride and Polyol Ester Oil (planetelf ACD 32)

Solubility And Miscibility For The Mixture Of (Ethyl Fluoride Plus Polyol Ester Oil)

Mutual Diffusivities of Difluoromethane and 2,3,3,3-Tetrafluoropropylene Dissolved in Polyalkylene Glycol Lubricant

Solubilities of Flame Retardant Trifluoroiodomethane (R13I1) in Polyol Ester and Polyvinyl Ether Lubricant Oil in the Temperature from 283.15 to 353.15 K

Isothermal Vapor–Liquid Equilibrium of the Absorption Working Pairs (HFC-32 + DMETrEG, HFC-32 + NMP) at Temperatures from 293.15 to 343.15 K

Experimental Investigation on Solubility and Viscosity of 1,1,1,2,3,3,3-Heptafluoropropane (r227ea) and Polyol Ester Oil (POE 22) Mixtures

Vapor–liquid Equilibrium of Difluoromethane +1,1,1,2-Tetrafluoroethane Systems over a Temperature Range from 258.15 to 343.15K

Solubilities of Dodecylpolyoxyethylene Polyoxypropylene Ether in Supercritical Carbon Dioxide

Solubility and Miscibility for the Mixture of (ethyl Fluoride + Alkylbenzene Oil)

Solubilities of 3, 3, 3-Trifluoropropene in Pentaerythritol Tetrahexanoate and Pentaerythritol Tetraoctanoate from 278.15 K to 343.15 K at Pressures to 1 MPa

Solubility Measurements of R1234ze(E), R1243zf, and R1234yf in POE46 at Temperatures from 283.15 to 343.15 K

Solubilities of R32, R245fa, R227ea and R236fa in a Phosphonium-Based Ionic Liquid

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

Solubilities of R-1233zd(E) in Three Lubricating Oils and Impact of Oil Retention on the Evaporator Performance

Vapor Liquid Equilibrium Measurements for Difluoromethane (R32) + 2,3,3,3-Tetrafluoroprop-1-ene (r1234yf) and Fluoroethane (R161) + 2,3,3,3-Tetrafluoroprop-1-ene (R1234yf)

Vapor-liquid Equilibrium of 3,3,3-Trifluoropropene with Mineral Oils and POE Lubricant Between 283.15 K and 343.15 K

Solubility study of carbon dioxide in pentaerythritol esters: Based on SAFT-VR-Mie equation of state