Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

Solubilities of R-1233zd(E) in Three Lubricating Oils and Impact of Oil Retention on the Evaporator Performance

Solubility of R-1233zd(E) in PVE 68 Oil and the Oil Presence Impact on Evaporator Performance

Measurement of Phase Equilibrium for R-1233zd(E) with Three Pure Esters between 298.15 and 343.15 K

Impact of oil presence on the evaporator enthalpy working with R1234ze(E) and R1234yf

Solubility And Miscibility For The Mixture Of (Ethyl Fluoride Plus Polyol Ester Oil)

Phase Behavior and Enthalpies of Binary Mixtures of R-1243zf with PAG 68, POE 85 and PEC4 Oils

Experimental Investigations for the Phase Equilibrium of R1234yf and R1234ze(E) with Two Linear Chained Pentaerythritol Esters

Phase Equilibrium of R1234yf and R1234ze(E) with POE Lubricant and Thermodynamic Performance on the Evaporator

Solubilities of 3, 3, 3-Trifluoropropene in Pentaerythritol Tetrahexanoate and Pentaerythritol Tetraoctanoate from 278.15 K to 343.15 K at Pressures to 1 MPa

Experimental study of ternary mixture R32/R125/R161 as alternative refrigerant to R407C

Experimental Investigation for the Solubility of R1234ze(E) in Pentaerythritol Tetrahexanoate and Pentaerythritol Tetraoctanoate

Experimental Data and Description of the Phase Equilibrium in the Binary System of Ethyl Fluoride and Polyol Ester Oil (planetelf ACD 32)

Isothermal Vapor–Liquid Equilibria of the Absorption Working Pairs (r1234yf + NMP, R1234yf + DMETrEG) at Temperatures from 293.15 K to 353.15 K

Experimental Investigation for the Solubilities of 2,3,3,3-Tetrafluoroprop-1-ene (r1234yf) in Polyol Ester, Polyvinylether, and Polyalkylene Glycol Base Oils

Investigation on the Vapor–Liquid Equilibrium for the Ternary Mixture HFC-32 + HFC-125 + HFC-161 at Temperatures from 265.15 K to 303.15 K

Solubility Measurements of R1234ze(E), R1243zf, and R1234yf in POE46 at Temperatures from 283.15 to 343.15 K

Absorption Behavior for R1234ze(E) and R1233zd(E) in [p66614][cl] As Working Fluids in Absorption Refrigeration Systems

An experimental investigation and correlation of the viscosity refrigerant/oil solutions

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

Measurement and Correlation for the Viscosity of R1234yf/POE85 and R1234ze(E)/POE85 Solutions

Solubilities of R32 in Polyol Ester and Polyvineyl Ether from 278.15 to 348.15 K