Abstract:During the commissioning of Nuclear power plant unit, it is necessary to perform the transient condition test that the single pump operation of Main Feedwater (APA) pump triggers the rapid load rejection of steam turbine. Due to the sudden loss of a main water supply pump during the test, the level of the steam generator will change dramatically. If there is a signal of "SG level low plus steam / water flow mismatch" or a signal of "SG level low low", the reactor trip protection will be triggered. PI controller is used as the core controller of the main feed water pump control process. The optimal parameters of PI controller directly affect the level control performance of steam generator. At present, the units that have completed the test only verify that the control system meets the requirements of transient conditions, but it does not solve the phenomenon that the oscillation frequency of the feed water regulating system is too high under stable conditions. In this paper, the safety range of the control parameters under transient condition is determined by simulation model test, and then the steady-state performance of the parameters is improved by field test, so the optimization of the control parameters is completed, and the regulation performance of the feed water control system under single pump operation and steady-state condition of the main feed water pump is improved, and practical results are achieved. The results show that the optimization of the controller parameters in this paper can meet the requirements of transient conditions, and can effectively increase the stability of the control system. This research method has been successfully applied in generation II unit, and it is also useful for the generation-III unit.

Research on overspeed protection control strategies of PWR nuclear power units

Coordination and Control Principle Between Grid-related Protection of Large-scale Nuclear Units and Security Automatic Devices of Power Grids

Coordinated protection and control between largecapacity nuclear power plants and power grids

Study on Optimization of PID for Feed-water Control System of RB Test in PWR Nuclear Power Station

Research on protection control strategy of pressurized water reactor nuclear power units for typical power system faults

Interaction and Coordination among Nuclear Power Plants, Power Grids and Their Protection Systems

Research And Practice Of Overpressure Protection System For Epr Primary Hydrostatic Test

INFLUENCE OF USING OVER SPEED PROTECTION CONTROL OF STEAM TURBINE UPON THE FREQUENCY IN POWER GRID AND COUNTERMEASURES THEREOF

Research on load rejection protection of PWR power plants at different power levels

The influence of the over-speed protection control for the isolated grid stability

PD Power-Level Control Design for PWRs: A Physically-Based Approach

Dynamic Modeling and Intelligent Hybrid Control of Pressurized Water Reactor NPP Power Transient Operation

Modeling and Simulation of Nuclear Power Units for Primary Frequency Regulation Research

A coordinated control methodology for small pressurized water reactor with steam dump control system

Capacity Limitation of Nuclear Units in Grid Based on Analysis of Frequency Regulation

Analysis of Load-Following Characteristics for an Integrated Pressurized Water Reactor

Development of a Simulation Platform for Studying on Primary Frequency Regulation Characteristics of Nuclear Units

Real-time simulations to enhance distributed on-line monitoring and fault detection in Pressurized Water Reactors

Impact of Overspeed Protection Control on Stability for Islanded Power System

Adaptive Proportional-Differential Power-Level Control for Pressurized Water Reactors

Risk-Oriented Preventive Control of Transmission Lines Overload