Abstract:The removal of nitrogen oxides under a high pressure has been widely accepted as an effective method for the treatment of oxy-fuel combustion flue gas. The high pressure promotes the oxidation of NO to NO2, subsequently removed by water to form nitric acid. However, both the measurement and modeling of nitrogen oxides absorption shows uncertainties. To quantify the nitrogen mass balance, gas-phase NO/NO2 and HNO2 were measured online, whereas liquid-phase HNO2 and HNO3 were analyzed offline. Nitrogen mass balance was achieved with a relative error within +/- 8%. To improve modeling accuracy, a novel multiparameter optimization method was proposed. Mass transfer coefficients of NO2/NO, rate constant of NO oxidation, surface area, and volume of liquid were optimized. The absorption of NO2 into a liquid was dominated by gas-phase mass transfer with the mass transfer coefficient decreasing from 1.77 x 10(-4) mol m(-2) s(-1) Kpa(-1) to 1.26 x 10(-4) mol m(-2) s(-1) Kpa(-1) with the increase of reactor pressure from 5 bar to 20 bar. The pressure dependent rate constant for NO oxidation agreed with gas-phase NO oxidation experimental measurement. It first decreased with the reactor pressure from 5 bar to 15 bar followed by an increase from 15 bar to 20 bar. The surface area of liquid decreased while the liquid volume increased with the rising reactor pressure indicating that liquid droplets were formed by gas bubbling and attached onto the inner surface of the reactor. This study resolved the uncertainties in measurement and modeling of the nitrogen oxides absorption process.

An empirical model of absorption of nitric oxide with ammoniacal cobalt (II) solutions in a Spray Tower

Experimental Study on Carbon Dioxide Absorption by Aqueous Ammonia with Nickel and Chromium Ions in Bubbling Tower at Low Temperatures

On the kinetics of the absorption of nitric oxide into ammoniacal cobalt(II) solutions

Numerical Simulation of No2 Absorption Using Sodium Sulfite in A Spray Tower

Volumetric Overall Mass Transfer Coefficients of CO_2 Absorption Into Aqueous Ammonia of Fine Spray

The Absorption Rates of CO2 by Aqueous Ammonia Solution in a Spray Column

Nitric oxide absorption into cobalt ethylenediamine solution

Experimental and Numerical Study on CO2 Absorption Mass Transfer Enhancement for a Diameter-Varying Spray Tower

Mass transfer and reaction kinetics of NO absorption with aqueous ferrous cysteine solution in double-stirred cell

Studies on the absorption of nitric oxide by ferrous cysteine solution

A pilot scale study on absorption of low concentration nitrogen oxides in exhaust gas with water

Measurement and Modeling of Nitrogen Oxides Absorption in a Pressurized Reactor Relevant to CO2 Compression and Purification Process

Kinetic Studies on NO2Absorption into Ammonium Sulfite Solutions

Experimental Investigation of Nitric Oxide Removal from Flue Gas Using Hexamminecobalt(ii) Solution Scrubbing in a Pilot-Scale Facility

Kinetics of NOx absorption into (NH4) 2SO3 solution in an ammonia-based wet flue gas desulfurization process

Kinetics of No Absorption in Aqueous Iron (ii)thiochelate Solutions

Oxidative catalytic absorption of NO in aqueous ammonia solution with hexamminecobalt complex

Kinetic Modeling of Non-Hydrocarbon/nitric Oxide Interactions in a Flow Reactor above 1,400K

KINETICS OF GAS-LIQUID REACTION OF NO WITH Co (NH3)2+6

Kinetics of gas-liquid reaction between NO and Co(NH3)6(2+).

Performance of CO2 Absorption in a Diameter-Varying Spray Tower