Abstract:Factors affecting rhenium reduction and the degree of bimetallic cluster formation were studied for Pt-Re/Al2O3catalysts. Temperature programmed reduction (TPR) and X-ray absorption near edge structure (XANES) were used to examine Pt catalyzed reduction of Re following a series of thermal pretreatments and suggest that chloride on the Al2O3 support plays a major role in Pt-Re alloying during reduction. A critical review of published data on the role of chloride and sulfur and their interaction with both the precursors and metal cluster to form an active reforming catalyst is also presented. To minimize yield-octane loss via hydrocracking, hydrogenolysis and low activity, the active metal sites of Pt-Re/Al2O3 catalysts must be carefully constructed so as to maximize the number of well-dispersed Pt-Re alloy clusters and essentially eliminate the presence of isolated Re atoms. Alloy clusters are formed by the catalytic reduction of Re species by immobile Pt°, and the Re species must be mobile on the alumina surface. Two mobile Re species are believed to exist, a hydrous Re oxide and a Re oxychloride. Pt°-catalyzed reduction of hydrous Re oxide, a wet reduction, is undesirable for two reasons. Water strips chloride from the alumina and can remove Re from Pt-Re alloy clusters. For the preferred dry reduction of a Re oxychloride to be successful, it is critically important that there be adequate Cl to provide Re mobility. Experimental data generated by TPR and XANES support this reasoning. The function of the S added to Pt-Re/Al2O3 catalyst is to confine activity of the Pt to hydrogenation- dehydrogenation. It is shown that the amount of irreversibly adsorbed sulfur, S(irr) is an equilibrium value dependent on temperature and H2S partial pressure. However, there must be enough S(irr) present to sulfide all the Re and about 10%of the Pt at the stoichiometry of Pt2S and Re2S. If the S(irr) is too low, either through undersulfiding or overstripping, catalyst performance suffers. Reversibly adsorbed sulfur, S(rev), is also an equilibrium value dependent on temperature and H2S partial pressure. Activity maintenance of Pt-Re/Al2O3 catalysts is decreased by S(rev). As the Re to Pt atomic ratio increases, adverse sensitivity of the catalyst to S(rev) also increases.

Deactivation of rhenium-based catalysts for the metathesis of propene

Structure and activity of rhenium-based metathesis catalysts

Insights into the Deactivation Mechanism of Heterogeneous Mo/H Beta-Al2o3 Catalysts for Olefin Metathesis

In situ-DRIFTS study: influence of surface acidity of rhenium-based catalysts in the metathesis of various olefins for propylene production

Olefin Metathesis over Heterogeneous Catalysts: Interfacial Interaction Between Mo Species and a Hβ−Al2O3 Composite Support

Rhenium As a Promoter for Ethylene Epoxidation.

Insight into the influence of Re and Cl on Ag catalysts in ethylene epoxidation

Performance Descriptors for Catalysts Based on Molybdenum, Tungsten, or Rhenium Oxides for Metathesis of Ethylene with 2-Butenes to Propene

The “Catalytic Nitrosyl Effect”: NO Bending Boosting the Efficiency of Rhenium Based Alkene Hydrogenations

RE2O3-promoted Pt–SO42−/ZrO2–Al2O3 Catalyst in N-Hexane Hydroisomerization

Hydrothermal Study of Pt–Sn-based SAPO-34 Supported Novel Catalyst Used for Selective Propane Dehydrogenation to Propylene

Propane Dehydrogenation over Supported Pt and Pt–Sn Catalysts: Catalyst Preparation, Characterization, and Activity Measurements

The roles of chlorine and sulfur in bimetallic Pt-Re/Al2O3 reforming catalyst

CO 2 Hydrogenation to Methanol on Indium Oxide-Supported Rhenium Catalysts: The Effects of Size

Deactivation of ir-re alloy catalyst in glycerol hydrogenolysis

Bimetallic platinum rhenium catalyst for efficient low temperature dehydrogenation of perhydro benzyltoluene

Stabilization of the Active Ruthenium Oxycarbonate Phase for Low-Temperature CO 2 Methanation

Modeling the Selectivity of Hydrotalcite-Based Catalyst in the Propane Dehydrogenation Reaction

In Situ DDR-UV-Vis and Raman spectroscopic study of titania promoting effect on silica supported tungsten catalysts for enhanced propylene metathesis

Supported Al–Ti Bimetallic Catalysts for 1-Decene Oligomerization: Activity, Stability and Deactivation Mechanism

Rhenium Alkyne Catalysis: Sterics Control the Reactivity