Abstract:The Ca12Al14O33 ceramic (C12A7) and reduced graphene oxide (rGO) composite which an ultra-high amount (i.e., 40, 50, 60, and 70 wt%) of rGO (ultra-high amount C12A7/rGO composite) were synthesized by a solid-state reaction process. After the hydraulic press, the heat treatment in the temperature range of 773 K under the argon environment had been performed with the composite pellets for 30 min. XRD results of the C12A7 and all the ultra-high amount C12A7/rGO composites indicated a pure phase of C12A7 ceramic. Raman spectra confirmed the existence of rGO content in all the ultra-high amount C12A7/rGO composites. Raman peaks also suggested reduction of the free O22- and O2- ions from the framework of the ultra-high amount C12A7/rGO composites. SEM image presented the homogeneous grain boundary interface after the heat treatment at 773 K of the C12A7 wrapped by the rGO sheet, the agglomerated rGO sheet, and the rough interface stack of rGO sheets. UV-VIS spectroscopy presented the absorption behavior, direct energy gap, and indirect energy gap modifications of the ultra-high amount C12A7/rGO composites. Electrical conductivity of the ultra-high amount C12A7/rGO composites illustrated larger than 108 times improvement with temperature independence. Range of -5 to -17 μV/K , temperature dependence, and increased with rGO content increasing Seebeck coefficient were reported. Thermal conductivity of the ultra-high amount C12A7/rGO composites was increased with the rGO content increasing. Both the Power factor (PF) and the figure of merit (ZT) of the ultra-high amount C12A7/rGO composites were temperature dependent and were increased with the rGO content increasing, within the range of 0.4 μW/m.K2 of PF and the range of 3x10-4 of ZT, respectively. These experimental results verified grain boundary, modified energy band, electrical transport properties and thermoelectric properties of C12A7/rGO composites loading with ultra-high content rGO.

Enhanced thermoelectric properties and thermal stability of Cu1.8S-rGO nanocomposite by low energy carrier filtering effect

Boosting the thermoelectric performance of n-type Bi2S3 by compositing rGO

Enhanced thermoelectric properties of Cu1.8S via the introduction of ZnS nanostructures

Enhancement of Thermal Conductivity and Mechanical Properties of Cu-Reduced Graphene Oxide Composites by Interface Modification

Enhanced thermoelectric properties of In-filled Co4Sb12 by dispersion of reduced graphene oxide

Graphene Network in Copper Sulfide Leading to Enhanced Thermoelectric Properties and Thermal Stability

Synthesis of Thermoelectric Nanocomposites by Incorporating Reduced Graphene Oxide

Balance thermal conductivity and thermal expansion in RGO/Cu composites through alignment engineering

Excellent thermoelectric properties and stability realized in copper sulfides based composites via complex nanostructuring

Highly enhanced thermoelectric performance of copper sulfide by compositing with CNT & CuO

Thermoelectric Properties of Reduced Graphene Oxide/Bi2Te3 Nanocomposites

Grain boundary, electrical transport and thermoelectric properties of the ultra-high rGO amount of C12A7-rGO composites

Enhanced the thermal conductivity of flexible copper foil by introducing graphene

Enhancement of Thermal Management Performance of Copper Foil Using Additive–Free Graphene Coating

Construction of a 3D-Rgo Network-Wrapping Architecture in a YbyCo4Sb12/rGO Composite for Enhancing the Thermoelectric Performance

Microstructure Optimization in the Shear‐Exfoliated Bi6Cu2Se4O6 through Introducing Reduced Graphene Oxide Leads to Wide‐Ranged Thermoelectric Performance

Enhancing thermoelectric and mechanical properties of p-type Cu3SbSe4-based materials via embedding nanoscale Sb2Se3

Enhanced performance of thermoelectric nanocomposites based on Cu12Sb4S13 tetrahedrite

Selective Enhancement in Phonon Scattering Leads to a High Thermoelectric Figure-of-Merit in Graphene Oxide-Encapsulated ZnO Nanocomposites

Effect of energy filtering on Cu2NiSnS4/CuO composites for thermoelectric applications

Enhanced Thermoelectric Performance of CuGaTe2 Based Composites Incorporated with Graphite Nanosheets