Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Pressure-decay and thermodynamic characteristics of subcooled liquid in the tank and their interaction with flashing jets.

Dynamic Behaviors of In-Tank Subcooled Liquid with Depressurization-Induced Phase Change and the Impact on Primary Breakup of Flashing Jet

Droplets Behaviors of Flashing Jet in Accidental Release of Superheated Liquid

Thermal Nonequilibrium and Mechanical Forces Induced Breakup and Droplet Formation of Superheated Liquid Jets under Depressurized Release

In-nozzle flow of superheated liquid release and the influence on the external flashing jet using transparent nozzles

Breakup Regime of Flashing Jet under Thermal Nonequilibrium and Mechanical Forces and Its Relationship with Jet Characteristics During Depressurized Releases of Superheated Liquid

Droplet Evaporation to Boiling in Van Der Waals Fluid

Morphological Characteristics and Flashing Mechanism of Superheated Liquid Jets Released from Rectangular Breaches

Experimental Research on the Two-Phase Explosive Boiling Mechanism of Superheated Liquid under Different Leakage Conditions

Dynamic Thermal Performance of Cryogenic Liquid Hydrogen Heating from Gas-Liquid Stratification to Supercritical under a Constant Heat Flux Condition: A Two-Step Simulation

Experimental study on boiling mechanism of superheated liquid containing ethanol impurity under different leakage conditions

Flow visualization of the transient effect of the internal two-phase flow on the external iso-pentane flashing spray under different injection pressure

Influence of Thermal Stratification by Fire on Heat-Mass Coupling Response Mechanism of the Liquefied Tank

Theoretical investigation on heat leakage distribution between vapor and liquid in liquid hydrogen tanks

Numerical Analyses of Flashing Jet Structure and Droplet Size Characteristics

Study on mechanism and law of liquid overheating and explosive boiling caused by leakage

An exploration on collapse mechanism of multi-jet flash-boiling sprays

Two-Phase Expanding Mechanism And Pressure Response Characteristic Of Boiling Liquid Expanding Vapor Explosion Under Rapid Depressurization

Experimental Study on Gas-Liquid Flow Characteristics of Submerged Air Jets

Direct simulation of flashing liquid jets using the MPS method

LES model of flash-boiling and pressure recovery phenomena during release from large-scale pressurised liquid hydrogen storage tank