Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Numerical Study of Condensation Flow Regimes in Presence of Non-Condensable Gas in Minichannels

Numerical Simulation and Experimental Study of Capillary Tubes

Numerical Investigation of Condensation Heat Transfer Characteristics of R134A in Rectangular Minichannel

Visualization of R1233zd(E) Flow Boiling in Parallel Mini-channels

Investigating the Thermal-Hydraulic Performance of New Refrigerant Mixtures Through Numerical Simulation of Minichannel and Microchannel Evaporators

Condensation Heat Transfer and Flow Properties of R134a Refrigerant in Rectangular Minichannel: A Numerical Study

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Numerical simulation of condensation in horizontal circular and square minichannels using R134a

Numerical Simulation of Flow Patterns and the Effect on Heat Flux During R32 Condensation in Microtube

Numerical Analysis of Laminar Convective Condensation with the Presence of Noncondensable Gas Flowing Downward in a Vertical Channel

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Numerical Simulation of Condensation for R410a in Horizontal Round and Flattened Minichannels

A numerical study of condensation heat transfer and pressure drop in horizontal round and flattened minichannels

Phase Change and Heat Transfer Analysis of Different Refrigerants During Condensation in Minichannel Using a Novel Numerical Approach

Flow condensation inside a multiport mini channel and a rectangular mini channel with pin fin array

Experimental Investigation on Heat Transfer of R1234ze and R22 During Condensation in Minichannels

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube

Evaporative annular flow in micro/minichannels: A simple heat transfer model

Simulation of Condensation Flow in A Rectangular Microchannel

Numerical simulation on the effect of non-condensable gas on direct contact condensation of steam jet in a narrow pipe

Experimental study on condensation heat transfer of R32, R152a and R22 in horizontal minichannels