Abstract:<math>{101¯2}</math> twins were introduced into the magnesium (Mg) plate AZ31 via pre-rolling along its transverse direction. The plates, both with and without the pre-induced <math>{101¯2}</math> twins, were subjected to uniaxial tension along different directions. Using crystal plasticity modeling, we found that the strengthening effect of the pre-induced <math>{101¯2}</math> twins on the macroscopic flow stress primarily arised from the increased slip resistance caused by the boundaries, rather than the orientation hardening due to the twinning reorientation (although the latter did make its contribution in some specific loading directions). Besides, the pre-existing <math>{101¯2}</math> twins were found, by both experiments and simulation, to promote the activity of prismatic 〈a〉 and pyramidal 〈c + a〉 in the parent matrix of the material. Further analysis showed that the enhanced non-basal slip activity is related to the <math>{101¯2}</math> twin boundaries' low micro Hall-Petch slope ratios of non-basal slips to basal slip. With the critical resolved shear stress (CRSS) obtained from crystal plasticity modeling and the orientation data from EBSD, a probability-based slip transfer model was proposed. The model predicts higher slip transfer probabilities and thus lower strain concentration tendencies at <math>{101¯2}</math> twin boundaries than that at grain boundaries, which agrees with the experimental observation that the strain localization was primarily associated with the latter. The present findings are helpful scientifically, in deepening our understanding of how the pre-induced <math>{101¯2}</math> twins affect the strength and slip activity of Mg alloys, and technologically, in guiding the design of the pre-strain protocol of Mg alloys.

Effects of Precipitate Type on Twin/slip Activity in ZK60 Alloys and Yield Asymmetry

The Yield Asymmetry and Precipitation Behavior of Pre-Twinned ZK60 Alloy

Effect of Precipitates in Mg−Sm Alloys on Their Deformation Behavior and Yield Asymmetry

Effect of pre-induced precipitations on microstructure evolution and the mechanical properties of pre-twinned ZK61 Mg alloys at elevated temperatures

Strengthening Against {101¯2} Twinning by Discontinuous and Continuous Precipitate in a Strongly Textured Mg-9Al Alloy

Strengthening Against {10(1)Over-Bar2} Twinning By Discontinuous And Continuous Precipitate In A Strongly Textured Mg-9al Alloy

An Investigation of Slip and Twinning Behavior of a Zirconium Alloy During Plastic Deformation Based on In-Situ SEM-EBSD

Effects of extrusion ratio and subsequent heat treatment on the tension-compression yield asymmetry of Mg-4.58Zn-2.6Gd-0.18Zr alloys

Role of Volume Fraction of Second Phase Particles, Dislocation-Twin and Twin-Twin Interactions in the Reduced Tension-Compression Yield Asymmetry

The Precipitation Behavior of a Pretwinned Mg–6Al–1Zn Alloy and the Effect on Subsequent Deformation

Effects of initial grain size and orientation on the twin behavior in ZK60 Mg alloy

Effect of Precipitates on the Dominant Active Slip Systems in Mg-4.5Zn (wt.%) Alloy

On the strengthening and slip activity of Mg-3Al-1Zn alloy with pre-induced { 10 1 ̄ 2 } twins

Interactions Between Twins and Dislocations in ZK60 Alloy under Dynamic Compression

Reducing the Tension-Compression Yield Asymmetry in an Extruded ZK60 Alloy by Ultrafine Grains

Quasi-in-situ investigation on extension twinning behavior of extruded ZC61 alloy during dynamic compression

Interaction Between Slip and {101¯2} Tensile Twinning in Zr Alloy: Quasi in Situ Electron Backscatter Diffraction Study under Uniaxial Tensile Test

Modeling the Micromechanical Behaviors of Zircaloy-2 Alloy under Large Deformation

The Effect of Precipitates on the Mechanical Properties of ZK60-Y Alloy

Effects of Precipitate on the Slip Activity and Plastic Heterogeneity of Mg-11Y-5Gd-2Zn-0.5Zr (wt. %) During Room Temperature Compression

Influence of Pre-Twinning on High Strain Rate Compressive Behavior of AZ31 Mg-alloys