Abstract:Structural transitions of polyamide 46 (PA46) films during the tensile stretch at temperatures from 37 to 249 °C were studied using in situ synchrotron radiation wide-angle X-ray diffraction (SR-WAXD) and Fourier transform infrared (FTIR) techniques. The structural evolution during the stretch at different temperatures can be roughly divided into three regions. In region I (37 ≤ T < 180 °C), stretch enlarges the d-spacing gap between the (100) and (010/110) planes of α phase (triclinic), which is opposite to that during heating. In region II (180 ≤ T < 230 °C), stretch induces a reverse Brill transition, which is characterized by the single diffraction of γ phase (pseudohexagonal) splitting into two diffractions of α phase, while further increasing the strain drives the two split diffractions to transform to a single broad diffraction. As in situ FTIR measurements reveal the continuously increasing content of trans conformation, we speculate that stretch may induce a new form, which is an intermediate structure close to both α and γ phases (named α′ phase) at large strain. In region III (230 ≤ T ≤ 249 °C), the γ phase may skip the α phase and directly transform into the α′ phase. The nonequilibrium crystal phase diagrams of PA46 were constructed in the strain–temperature space and true stress–temperature space. Current results demonstrate that stretch plays a countereffect of heating on the Brill transition of PA46.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.macromol.0c00542?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.macromol.0c00542</a>.Crystal structure confirmation of PA46; the possible unit cell orientation and WAXD pattern of spherulitic aggregates; 1D WAXD integration profiles and the corresponding quantitative results; and in situ FTIR curves and stress–strain curves for FTIR experiments (<a class="ext-link" href="/doi/suppl/10.1021/acs.macromol.0c00542/suppl_file/ma0c00542_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Structural Evolution and Phase Transition of Uniaxially Stretched Poly(butylene Adipate-Co-butylene Terephthalate) Films As Revealed by in Situ Synchrotron Radiation Small and Wide Angle X-ray Scattering

Structural Evolutions of Initially Amorphous Polymers During Near-Tg Stretching: A Minireview of Recent Progresses

Structure Evolution and Properties Enhancement of Polyamide‐6/polyamide‐1010 Films under Uniaxial and Biaxial Stretching

Effects of stretching on crystalline phase structure and morphology of hard elastic PVDF fibers

Stretch-induced structural transition of linear low-density polyethylene during uniaxial stretching under different strain rates

Stretch-induced structural evolution of pre-oriented isotactic polypropylene films: An <i>in-situ</i> synchrotron radiation SAXS/WAXS study

Stretch-Induced Α-to-β Crystal Transition and Lamellae Structural Evolution of Poly(butylene Adipate-Ran-terephthalate) Aliphatic–Aromatic Copolyester

Stretch-Induced Bidirectional Polymorphic Transformation of Crystals in Poly(Butylene Adipate)

Stretch-induced structural evolution of pre-oriented isotactic polypropylene films: An in-situ synchrotron radiation SAXS/WAXS study

Real Time Synchrotron SAXS and WAXS Investigations on Temperature Related Deformation and Transitions of Β-Ipp with Uniaxial Stretching

Segmental Orientations and Deformation Mechanism of Poly(Ether-Block-Amide) Films

Deformation Mechanisms of Polymer Thin Films by Simultaneous Kinetic Measurement of Microscopic Infrared Dichroism and Macroscopic Stress. Part Iii: Influence of Morphology on Molecular Orientation of Isotactic Polypropylene Films Subjected to Uniaxial Stretching

Stretch-Induced Reverse Brill Transition in Polyamide 46

Strain-Rate-Dependent Phase Transition Mechanism in Polybutene-1 during Uniaxial Stretching: From Quasi-Static to Dynamic Loading Conditions

Structural evolution of biaxially oriented polypropylene films upon asynchronous stretching

Stretch-induced crystalline structural evolution and cavitation of poly(butylene adipate-ran-butylene terephthalate)/poly(lactic acid) immiscible blends

Polymorphic Crystal Transition and Lamellae Structural Evolution of Poly(p-dioxanone) Induced by Annealing and Stretching.

Structural Evolution of Hard-Elastic Polyethylene Cast Film in Temperature-Strain Space: an In-Situ SAXS and WAXS Study

Deformation Mechanism of Hard Elastic Polyethylene Film During Uniaxial Stretching: Effect of Stretching Speed

In Situ Study of Nanostructure and Morphological Development During the Crystal–mesophase Transition of Poly(di-N-hexylsilane) and Poly(di-N-butylsilane) by X-ray and Hot-Stage AFM

Structural evolution of cellulose triacetate film during stretching deformation: An in-situ synchrotron radiation wide-angle X-Ray scattering study