Abstract:The growth and structural properties of ZnO thin films on Zn atoms both Au(111) and Cu(111) surfaces were studied using either NO2 or O-2 as oxidizing agent. The results indicate that NO2 promotes the formation of well-ordered ZnO thin films on both Au(111) and Cu(111). The stoichiometric ZnO thin films obtained on these two surfaces exhibit a flattened and non-polar ZnO(0001) structure. It is shown that on Au(111), the growth of bilayer ZnO nanostructures (NSs) is favored during the deposition of Zn in presence of NO2 at 300 K, whereas both monolayer and bilayer ZnO NSs could be observed when Zn is deposited at elevated temperatures under a NO2 atmosphere. The growth of bilayer ZnO NSs is caused by the stronger interaction between two ZnO layers than between ZnO and Au(111) surface. In contrast, the growth of monolayer ZnO NSs involves a kinetically controlled process. ZnO thin films covering the Au(111) surface exhibits a multilayer thickness, which is consistent with the growth kinetics of ZnO NSs. Besides, the use of O-2 as oxidizing agent could lead to the formation of substoichiometric ZnOx structures. The growth of full layers of ZnO on Cu(111) has been a difficult task, mainly because of the interdiffusion of Zn promoted by the strong interaction between Cu and Zn and the formation of Cu surface oxides by the oxidation of Cu(111). We overcome this problem by using NO2 as oxidizing agent to form well-ordered ZnO thin films covering the Cu(111) surface. The surface of the well-ordered ZnO thin films on Cu(111) displays mainly a moire pattern, which suggests a (3 x 3) ZnO superlattice supported on a (4 x 4) supercell of Cu(111). The observation of this superstructure provides a direct experimental evidence for the recently proposed structural model of ZnO on Cu(111), which suggests that this superstructure exhibits the minimal strain. Our studies suggested that the surface structures of ZnO thin films could change depending on the oxidation level or the oxidant used. The oxidation of Cu(111) could also become a key factor for the growth of ZnO. When Cu(111) is pre-oxidized to form copper surface oxides, the growth mode of ZnOx is altered and single-site Zn could be confined into the lattice of copper surface oxides. Our studies show that the growth of ZnO is promoted by inhibiting the diffusion of Zn into metal substrates and preventing the formation of sub-stoichiometric ZnOx. In short, the use of an atomic oxygen source is advantageous to the growth of ZnO thin films on Au(111) and Cu(111) surfaces.

Controlled Growth of Uniform Two-Dimensional ZnO Overlayers on Au(111) and Surface Hydroxylation

Growth of Ordered ZnO Structures on Au(111) and Cu(111)

Controlled growth of 1D and 2D ZnO nanostructures on 4H-SiC using Au catalyst

Growth Of Single- And Bilayer Zno On Au(111) And Interaction With Copper

Growth, structure, and stability of Au on ordered ZrO2(111) thin films

Alignment-controlled Hydrothermal Growth of Well-Aligned ZnO Nanorod Arrays

Epitaxial Growth of Ultrathin ZrO2(111) Films on Pt(111)

Facile and Controllable Growth of ZnO 1D Nanostructure Arrays on Zn Substrate by Hydrothermal Process

Atomic layer deposition of ZnO on thermal SiO 2 and Si surfaces using N 2-diluted diethylzinc and H 2O 2 precursors

Unveiling the Atomic Structure and Growth Dynamics of One-Dimensional Water on ZnO(10-10).

Growth, Electronic Structure and Thermal Stability of Ni on ZrO2(111) Thin Film Surfaces

Controllable Growth of Highly Ordered ZnO Nanorod Arrays Via Inverted Self-Assembled Monolayer Template.

Nucleation Kinetics and Structure Evolution of Quasi-Two-Dimensional ZnO at the Air-Water Interface: An In Situ Time-Resolved Grazing Incidence X-ray Scattering Study

Direct Observation of the Layer-by-Layer Growth of ZnO Nanopillar by In situ High Resolution Transmission Electron Microscopy

Effects of Au on the growth of Zno nanostructures on Si by MOCVD

Controlled Synthesis of 1D ZnO Nanostructures Via Hydrothermal Process

Direct and Large-Area Growth of One-Dimensional ZnO Nanostructures from and on a Brass Substrate

Growth and Properties of Nano ZnO

Ordered ultra thin ZnO films on metal substrate

Superhydrophobic Multi-Scale ZnO Nanostructures Fabricated by Chemical Vapor Deposition Method

Influence of Oxygen Partial Pressure on the Adsorption and Diffusion During Oxide Growth: Zno(0001) Surface